2020 Volkswagen Atlas Cross Sport problems

“HVAC water tubing has leaked on to the airbag control module causing airbag errors and many other electrical faults. This is a known safety problem under recall 87H4, NHTSA campaign 21V892. However, Volkswagen stated my VIN is not eligible for this recall. Note: this diagnostic was not performed at a dealership but at an independent German car repair shop.”

“Air Bag error-seat occupant classification module-passenger side occupant detection sensor is defective. Air bag may not deploy upon impact. Confirmed that airbag sensor is defective at dealership. Airbag error first appeared one week ago at 75k miles. VW will not cover cost to repair defective air bag sensor.”

“Pulled out of driveway onto major road. Brake fluid alert showed up on dash. Brakes completely stopped working. Was able to roll the car to a stop. Called tow truck which delivered car to mechanic. Mechanic confirmed that there were no brakes and advised that the brake master cylinder leaked into the brake booster which caused the brake booster to be damaged. Mechanic needed to remove and replace the the brake master cylinder and the vacuum brake booster.”

“While traveling south on Wheeler Road at the underpass of the Long Island Expressway my 2020 Volkswagon Atlas Cross Sport's emergency braking system gets activated. This has happened multiple times at approximatly 12:20 AM while heading home from work. I took the car to the dealer but the dealer said there was no way to check what happened unless the diagnostic machine was connected at the time it happened. Again, this has happened multiple times, the most recent being both January second and the third. There is no reason why this happenes as it is dark and not a sunglare issue, therei s no change of lighting, no pavement changes or obstructions, and no traffic in front of me. When this happens it scares the hell out of me because there isnt any reason why I would expect it to happen thus creating a bit of a dangerous situation for me. Maybe others have reported the same issue to you that you did or could look into the cause of this, possible a radar or broadcast system that could be the cause of the sensor activation so maybe the issue can get corrected and prevent it from happening again. Thank You for any help you can provide. Sincerely, [XXX]”

“February 2025, just outside the warranty period, the hood latch had become disconnected/broken under the hood. There is a point where the two piece cable is joined under the hood and the cable breaks at this point. There is an obvious defect in the hood latch system and puts drivers at risk as the hood cannot be opened if needed possibly stranding a driver on the road with a non-functioning vehicle and no way to assess or repair the issue. Think low oil, overheating engine, no wiper fluid, fuse blown, no way to assess the issue. This is a common problem as found in internet forums. Many complaints have been filed with the NHTSA see campaign numbers 11693537, 11691685, 11681799, 11648046, 11630017. The fix involves removing the left front tire, removing the wheel well trim and and under fender skirting (25+ torx head screws), locating and opening cable junction box in the engine compartment from under the wheel well and pulling the cable with pliers to open the hood. The broken cable has to be removed by removing two interior panels inside the car cabin and pulling cable and grommet out. Then fishing replacement cable back through firewall into channel and up to…”

“steering went out completly and the SUV shut off in the middle of the street. had to restart car to get it home. SUV shut off in the middle of a turn. Had the SUV checked at dealership and they found a bad steering unit. I had the SUV in 3 times with the complaint and they found nothing until the warranty ran out. Neillo VW checked it in 2020,2021,2023 and say they found nothing,”