1999 Volkswagen Passat steering problems

“I OWN A 1999 VOLKSWAGEN PASSAT IN WHICH THE CONTROL ARMS, TIE ROD ENDS, BALL JOINTS, AND BUSHINGS ARE FAILING. BASED ON SOME INTERNET RESEARCH, THIS IS A COMMON FAILURE FOR SIMILAR MAKES, MODELS, AND YEARS. THE PROBLEM OCCURS EVERY DAY, AND IF LEFT UNATTENDED, RESULTS IN SAFETY PROBLEMS AT HIGHER SPEEDS. PARTS WILL BE REPLACED IN THE NEAR FUTURE AND OLD PARTS WILL BE RETAINED, IF IT IS FEASIBLE. *TR”

“ON MY VEHICLE, THE PASSENGER FRONT LOWER CONTROL ARM IS FAILING AT THE BALL JOINT. THERE ARE LOUD SCREECHES AT LOW SPEEDS WHEN PASSING OVER BUMPS COMING FROM THE BALL JOINT EVIDENCING THE INAPPROPRIATE WEAR. THIS WAS ADDRESSED AND REPLACED ACCORDING TO SERVICE BULLETIN "VM" WITH VOLKSWAGEN IN EARLY 2005, BUT THE PART IS WEARING IMPROPERLY AGAIN. FAILURE OF THIS PART COULD CAUSE LOSS OF STEERING AND COULD BE FATAL AT HIGHWAY SPEEDS. *TR”

“TL*THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. WHILE DRIVING AT ANY SPEED, THE CONTACT HEARD A THUMPING SOUND COMING FROM THE REAR OF THE VEHICLE. SHE DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO HEARING THE SOUND. THE VEHICLE WAS DIAGNOSED BY THE DEALER AND THE TIE RODS WERE REPLACED. NHTSA CAMPAIGN ID NUMBER 00V414000 (STEERING:LINKAGES:ROD:RELAY:CONNECTING) WAS REFERENCED. THE CURRENT MILEAGE WAS 65,829 AND FAILURE MILEAGE WAS 39,466.”

“TIE ROD ENDS EXCESSIVE WEAR. REQUIRED REPLACEMENT PRIOR TO ISSUANCE OF NYS INSPECTION @60K IN 07. TIE RODS PREVIOUSLY REPLACED BY DEALER UNDER RECALL IN 2001@ 19K. DIFFERENT RECALL IN 05 @ 50K FOR INSPECTION/REPLACEMENT OF CONTROL ARMS RESULTED IN INSPECTION ONLY. DEALER DID NOT FIND EXCESSIVE WEAR OF CONTROL ARMS OR TIE ROD ENDS. I DOUBT DEALERS INTEGRITY OR THAT THE SERVICE TECH WAS AWARE OF PREVIOUS TIE ROD REPLACEMENT. OBVIOUSLY THE ACCEPTABLE WEAR WOULD BE GREATER HAD THE PARTS BEEN IN SERVICE LONGER. DEFECTIVE CONTROL ARMS LEAD TO EXCESSIVE WEAR OF THE STEERING LINKAGES AND BALL JOINTS. THE VEHICLE HAS VERY LOW MILEAGE FOR ITS AGE AND HAS BEEN USED LESS THAN 6K A YEAR SINCE PURCHASE IN 05. COST FOR THE REPLACEMENT WAS $150 PARTS (MOOG TIE ROD ENDS), $90 LABOR, $75 FOR THE REQUIRED ALIGNMENT AND NYS TAX = ~$330. THIS IS SAFETY CONCERN AND EXCESSIVE WEAR FOR A PART THAT SHOULD HAVE AT LEAST A 60K LIFE EXPECTANCY. IT WOULD BE NORMAL FOR A VEHICLE TO TRAVEL 20K BETWEEN INSPECTIONS. FOR THE DEALER TO OK AT 50K AND AN INDEPENDENT INSPECTION FACILITY TO CONDEMN AT 60K IS SUSPICIOUS. THE PARTS WERE VISIBLY WORN AND DEFECTIVE BY PERSONAL INSPECTION. *TR”

“TL*THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. THE MANUFACTURER STATED THAT THE CONTACT'S VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V414000 (STEERING: LINKAGES: ROD: RELAY: CONNECTING). SHE FELT THAT HER VIN SHOULD BE INCLUDED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 56,740.”

“TL*THE CONTACT OWNS A 1999 VOLKSWAGEN PASSAT. THE VEHICLE FAILED INSPECTION DUE TO THE TIE RODS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TIE RODS WERE REPLACED. THE CONTACT STATED THAT THE STEERING WAS LOOSE. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA RECALL # 00V414000 NOR # 99V248000 (STEERING:LINKAGES:ROD:RELAY:CONNECTING). THE CURRENT MILEAGE IS 63,000 AND FAILURE MILEAGE WAS 62,800.”