2003 Volkswagen Passat fuel system, gasoline problems

“The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and informed the contact that the parts needed for the repair could not be found. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 07V375000 (Fuel System, Gasoline); however, the VIN was included but the vehicle was not repaired. The failure mileage was approximately 133,000.”

“The contact owns a 2003 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 06V017000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.”

“TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE REFUELING THE VEHICLE, IT STARTED TO LEAK FUEL FROM UNDERNEATH THE FUEL TANK. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,500. ...UPDATED 06-12-15 *BF THE CONSUMER STATED VW CUSTOMER SERVICE WAS ADVOCATING TO GET A NEW FUEL TANK INSTALLED FOR HIM AT NO COST. UPDATED 06/23/15*JB”

“NHTSA CAMPAIGN ID NUMBER: 08V156000 "FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE." NHTSA ACTION NUMBER: PE08008 THE CAR IS OOZING GASOLINE FROM TOP LEFT (DRIVER'S) SIDE OF GAS TANK. THERE IS A STRONG SMELL OF GASOLINE INSIDE AND OUTSIDE (OUTSIDE DUE TO A GAS PUDDLE). VW DEALER (VW DOWNTOWN LOS ANGELES) REFUSES TO GRANT THE REPAIR, ASKING FOR $140 INSPECTION FEE. VWOA REPRESENTATIVE SITES THE RECALL PERFORMED IN 2009. THE RECALL ( PE08008 ) ISSUED HAS 2 PARTS: 1) UNDERBODY HEAT SHIELD INSTALLATION. 2) "DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE." I SUSPECT THE SECOND PART WAS NOT FULFILLED, GIVEN THE EXACT NATURE OF MECHANIC FAILURE DESCRIBED. *TR”

“AS I WAS PARKING MY CAR IN THE SCHOOL PARKING LOT, A STRONG ODOR OF GASOLINE STARTED TO COME THROUGH THE VENTS. I OPEN THE HOOD AN A LINE BEHIND THE ENGINE BAY WAS SQUIRTING OUT GASOLINE DIRECTLY ONTO THE HOT SURFACE OF THE ENGINE. I CHECK ONLINE AND I SEE THAT THERE WAS APREVIOUS RECALL THE R5 RECALL BUT MANY OWNERS WERE BEING TOLD BY VOLKSWAGEN THAT IT'S NO LONGER COVERED OR THAT THERE VIN WASN'T COVERED EVEN THOUGH THE CAR WAS THE SAME YEAR ON THE RECALL. I CALLED VOLKSWAGEN ASWELL AND THEY MENTIONED TO ME THAT THERE WAS A RECALL BUT NO LONGER ACTIVE OR HAD BEEN SERVICED ALREADY. IT LEAKS WHEN IT'S ON OR NOT. *TR”

“TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, IT WOULD STALL. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 06V017000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 160,000.”