2003 Volkswagen Passat seats problems

“MY SON WAS DRIVING (IN MOTION) ON HWY 17 IN MILLER COUNTY MO WITH SEAT HEATER ON SATURDAY NOV. 28, 2020. SEAT CAUGHT ON FIRE. I HAD NOTICED WHEN I HAD SEAT HEATER ON PREVIOUSLY IT BECAME SO HOT AS TO BURN LEGS. THIS IS A SERIOUS PROBLEM. IT COULD HAVE BURNED MY CAR COMPLETELY. VERY DANGEROUS.”

“05/01/2019 CAR HAD A DEAD BATTERY---CHARGE OVER NIGHT STILL WOULD NOT START---HAD THE CAR TOWED TO AUTO SHOP--UPON ARRIVAL WITH KEY ON APPROX. 15 MIN DRIVE--SMOKE STARTED BILLOWING---DISCONNECTED BATTERY---DRIVERS SIDE SEAT WARMER COMPLETELY MELTED--MECHANIC SAYS UNIT PULLING 30 AMPS--THERE WAS A PREVIOUS RECALL--NOT SURE IF TOTALLY CORRECTED--DONOT WANT TO REPLACE IMMEDIATELY--PLEASE ADVISE”

“MY FRONT DRIVER SEAT WARMER WAS TURNED ON LOW. I COULD FEEL THE SEAT GETTING WARMER AND CHECKED TO BE SURE THE SETTING WAS NOT ON HIGH WHICH IT WASN'T. I THOUGHT MAYBE I WAS BEING SENSITIVE AND STUCK MY MITTEN UNDER MY THIGH. I THEN NOTICED A FUNNY SMELL AND SUDDENLY THINGS GOT VERY HOT AND STARTED TO BURN MY LEG AS I WAS DRIVING. I LOOKED DOWN AND ACTUALLY STARTED TO SEE SMOKE. I WAS NOT ABLE TO JUST PULL OVER BUT QUICKLY TURNED THE SEAT OFF. I PULLED OUT MY MITTEN AND FLEECE WAS ACTUALLY MELTED. I WAS A BLOCK OR TWO FROM WORK AND TRIED TO KEEP FROM SITTING COMPLETELY DOWN AS IT BURNED. I ARRIVED AND JUMPED OUT TO SEE A BLACKENED AREA AND HOLE IN MY SEAT!! THE CAR WAS SMELLING AND I AM STILL IN SHOCK OVER THIS. I HAVE LOOKED AND CAN'T FIND A RECALL ON THE SEAT. THIS IS VERY DISTURBING AND DANGEROUS. THIS SHOULD NOT HAPPEN NO MATTER HOW OLD THE CAR IS.”

“WE WERE JUST LEAVING OUR FRIENDS HOUSE IT WAS APPROX. 6AM IN MORNING LITTLE COLD OUT SO I TURNED ON THE SEAT WARMERS WHICH IS ALWAYS NICE TOUCH TO WARM YOU UP ON THOSE COLD MORNINGS, ANYHOW ABOUT 4-5MINUTES AFTER SEAT WARMERS WERE TURNED ON PASSENGER SIDE WHERE I WAS SITTING GOT RATHER WARM AND THEN HOT AND THEN ACTUALLY START SMOKING AND FLAMES CAME OUT THERE WAS FIRE RIGHT UNDER MY BOTTOM. I FREAKED OUT JUMPED OUT OF SEAT ..I WAS YELLING FIRE FIRE FIRE YOU COULD SMELL PLASTIC BURNING AS IT WAS SMOKING AND BURNING.MY BOYFRIEND POURED WATER ON AND SMOTHERED OUT THE FIRE WITH HIS JACKET I'M A BIT LEARY OF THE CAR BECAUSE I DON'T FEEL ITS SAFE. I HAD MY BOYFRIEND UNPLUG HARNESS UNDER SEAT AND NOW MY AIR BAG WARNING DEFAULT LIGHT AND BELL STAY ON. I AM SHOCKED TO SEE SEVERAL OTHER COMPLAINTS REGARDING THIS ISSUE AND THAT VW PEOPLE HAVEN'T ADDRESSED THIS. I FEEL THIS CAR IS A DEATH TRAP.VERY UNHAPPY WITH THIS VEHICLE.”

“TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 35 MPH, THE HEATED SEAT WAS ACTIVATED AND WITHIN TWO MINUTES, THE SEAT WAS UNBEARABLY HOT AND BURNED A HOLE THROUGH THE CONTACT'S PANTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.”

“ON SEPT 20 2013 MY WIFE SHOWED ME A SPRING THAT CAME FROM UNDER THE DRIVERS SEAT . IRONICALLY THE NEXT DAY THE AIRBAG LIGHT CAME ON AND WONT GO OFF . ABOUT A MONTH LATER A 2ND SPRING APPEARED IN THE FLOORBOARD .CAR WILL NOT PASS INSPECTION . VW REALLY NEEDS TO ADDRESS THIS . *TR”