2023 Volkswagen Taos engine problems

“The infotainment touch screen on my 2023 Volkswagen Taos has completely blacked out and failed, leaving my backup camera entirely inoperable. This has created a severe blind-spot hazard where I cannot safely reverse. On top of this failure, the vehicle has a chronic history of being in and out of the dealership service department for unresolved fuel system problems, specifically regarding the fuel injectors and fuel lines under warranty. The dealership has repeatedly failed to permanently fix this fuel defect. Now, the car actively loses engine acceleration and drops into a dangerous slow crawl ('limp mode') at busy intersections when the air conditioning is running, forcing me to turn off the climate control just to move safely. Combined, these recurring powertrain and electrical defects create an immediate, severe safety hazard for myself and my young children while driving.”

“Low coolant warning in red triangle showed up on my 2023 TAOS. Coolant in the reservoir was very low. I notice that there is a Technical Service Bulletin 15-23-01 rather than an official safety recall on 2022 and 2023 Taos 1.5T for head gasket coolant leak. There are many complaints regarding this issue on many message boards. We all fear that this problem will intensify as we all move out of powertrain warranty. Can you please instruct Volkswagen to have a recall on this issue? Thanks!”

“head gasket well known issue with no campaign or warranty coverage Volkswagen issued an official TSB 15-23-01 (Head Gasket Leakage) acknowledging that the original factory head gasket design on early Taos models allows coolant to leak. The production line was eventually updated with a redesigned gasket. They denied coverage or even partial reduction in labor.”

“On April 27, 2025, in [XXX] , the vehicle displayed a low coolant warning in the morning. The owner replenished the coolant as instructed, the warning cleared, and the vehicle was driven to work without incident. Later that day, while traveling southbound on [XXX] at approximately 60 mph, the engine overheat warning activated, forcing the driver to stop and pull over. The vehicle required two separate tows — first to the residence, then to the dealership the following day. On April 30, 2025, the dealership completed a full warranty repair replacing the engine head gasket and seals under TSB 2071245/1, a Volkswagen-issued Technical Service Bulletin acknowledging a known manufacturing defect in the 2022–2023 Taos cooling system, for which there is no recall issued. A formal case was opened with VW Customer Care prior to the repair visit and is on record. This incident occurred just before the vehicle’s warranty expiration at 30,000 miles.”

“This vehicle has a known design flaw which causes the cylinder gasket to leak and require replacement. VW has only issued a Technical Service Notice which was no provided to owners regarding the part that needed replacement. They are correcting the problem with a differently designed part in order to try to cure the design flaw. This can cause catastrophic engine failure. It should have been a recall. I should have been notified and the car should have been repaired at VW’s expense. They have explained since your agency didn’t issue a recall, they dot need to inform the public. Now they are expecting me to pay $3000 to correct their design error and also pay for rental car while it is under repair. This is a major violation of the lemon law, and yet there are numerous verified complaints. Issue a recall on the 2023 Taos, they are clearly scamming owners and leaving them in danger with a vehicle that has a faulty engine part. Owners like me, should have their car repaired by the responsible party, VW”

“I took the vehicle in to the VW dealership for service on 06/30/25 and they found that the head gasket had failed after only 26500 miles. A failed head gasket could lead to engine failure during operation which would create a significant safety issue.”