2006 Volvo XC70 problems

“The contact owns a 2006 Volvo XC70. The contact stated while attempting to start the vehicle, the front suspension springs fractured. The contact heard a loud clicking sound. There were no warning lights illuminated. The vehicle was taken to the local dealer who confirmed the fracture of the suspension springs. The passenger’s side suspension springs were replaced. The manufacturer was notified of the failure. The approximate failure mileage was 95,000.”

“When rear seats are folded to make more room for cargo, the seat belts retract more inwards due to the retractable hardware that retracts the belts. The button clips that are clamped into the belt that stops them from happening break apart easily due to the retracting force of the belt and when trying to fold back the seats the belts get locked and are unable to fold back to the original position, the only way to fix this is to unbolt the belts and fold back the seats and bolt back the seat belts. When this is done, passengers are not able to buckle in the rear seats due to the belt retractable hardware being locked. Is a safety issue because the passenger can not buckle and, when the belt works and are able to buckle, sometimes when braking hard the belt retrieves a little to keep the passenger in place and when this happens the belts lock back again having the passenger being tightened by the belt and unable to move freely and having difficulty trying to unbuckle in case of an emergency.”

“Takata Recall. The contact owns a 2006 Volvo XC70. The contact received notification of NHTSA Campaign Number: 21V800000 (Air Bags) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.”

“TL*THE CONTACT OWNS A 2006 VOLVO XC70. WHILE DRIVING APPROXIMATELY 65 MPH, THE SUN ROOF GLASS FRACTURED AND COMPLETELY SHATTERED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE SUN ROOF GLASS WAS REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 47,000.”

“IN HEAVY TRAFFIC MY VOLVO XC70 STA. WAGON (36K MI) SUDDENLY, AND W/OUT WARNING, SHUT DOWN. HAD BEEN DRIVING NON-STOP FOR 4-5 HRS. WD. NOT RESTART UNTIL 1.5 HRS. LATER. GRINDING NOISE NOTED WHEN KEY TURNED OVER. NO PRIOR HISTORY OF SAME. EXT. WARRANTY. DEALER "FOUND NO PROBLEMS" WHEN EXAMINED NEXT DAY. ONLY DROVE CAR 26MI. TO FURTHER TEST. VOLVO REP ALSO "TESTED" VEHICLE W/ OWN EQUIPMT. SHD. BE NOTED THAT, REPORTEDLY, DEALERSHIP'S COMPUTER HAD PROBLEM FUNCTIONING TWO DAYS LATER W/ ANOTHER CAR'S TESTING. DEALERSHIP STATED THAT PROBLEM HAD BEEN CORRECTED AND THAT MY VEHICLE HAD BEEN RETESTED. DAVID WHEELER VOLVO FEELS THEY HAVE FULFILLED THEIR OBLIG. TO US AND HAS ASKED US TO DRIVE IT OFF THE LOT. WE REFUSE TO DRIVE IT. *TR”

“MILEAGE ON THIS VEHICLE WAS 115K WHEN THIS HAPPENED: MY WIFE STARTED TO BACK THE CAR STRAIGHT OUT OF OUR DRIVEWAY (FROM A STOPPED POSITION, IN REVERSE GEAR) WHEN SHE HEARD A LOUD BANG WHICH CAME FROM THE DRIVERS SIDE FRONT OF THE VEHICLE. SHE STOPPED THE VEHICLE AND PLACED IT IN PARK. AFTER REMOVING THE LEFT FRONT WHEEL, I DISCOVERED THAT THE SUSPENSION COIL (OR SPRING) AS PART OF THE MACPHERSON STRUT ASSEMBLY, HAD SNAPPED IN TWO AT THE LOWER END. THE BROKEN OFF PART OF THE SPRING WAS SITTING ON THE LOWER CONTROL ARM, WHILE THE OTHER PART WAS STILL SURROUNDING THE STRUT. THAT PART OF THE SPRING WAS RESPONSIBLE FOR SLASHING THE TIRE WHEN IT FAILED. WE WERE THANKFUL THAT THIS HAPPENED ON OUR DRIVEWAY AND NOT GOING DOWN THE HIGHWAY AT A HIGH RATE OF SPEED. BUT WE WERE ALSO ASTOUNDED THAT SUCH A CATASTROPHIC FAILURE OF A SUSPENSION PART LIKE THIS WOULD OCCUR IN THE FIRST PLACE. THERE WERE NO RECALLS THAT WE WERE AWARE OF AND NOTHING IN THE SERVICE SCHEDULE ABOUT REPLACING THESE SPRINGS AT THE GIVEN MILEAGE.”