56 owner complaints to NHTSA about the 2016 Volvo XC90 cite electrical system, 28% of all 197 complaints for this model year. NHTSA also lists 1 recall on this component.
“SRS warning light and was told that is is due to a faulty misassembled wiring in the seat harness. Possibility of the airbags not deploying correctly in case of a crash. The dealer has confirmed that it is the seat harness that needs to be replaced. Due to the Month/Year of the vehicle it does not fall under the original recall which was only for vehicles that were manufactured between Jan/May 2015.”
“The contact owns a 2016 Volvo XC90. The contact stated that water had been leaking into the vehicle on rainy days. The contact stated that the water intrusion was causing several warning lights to illuminate and unknown vehicle safety equipment failures. The contact stated that the front and rear carpets and the spare tire were saturated with water. The contact had taken the vehicle to a local dealer, where it was determined that water was leaking into the vehicle, but the dealer was unable to determine the point of intrusion. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 168,000.”
“The hybrid motor periodical will hesitate when accelerating from a stop, specifically it'll start accelerating then lose power for up to a couple of seconds before regaining power. This poses a safety risk if you start pulling out into traffic and suddenly and unpredictably lose power while there's oncoming vehicles. The problem just occurred for the first time about a week ago and coincidentally just a few days after taking the car in for its annual service, since then it has happened more frequently and I can't find any rhyme or reason as to why it happens. The vehicle will be going in to be checked out shortly. There have been no warning lights any time this has happened.”
“The car has a factory fault with the Windshield Wiper or Turn Signal contact switch, which is causing the inability to use the left/right signal and the wipers. The entire part is factory faulty, rendering the vehicle unable to operate safely. This affects visibility during wet conditions because the wipers cannot be activated due to the malfunctioning switch, which can lead to serious accidents. Additionally, malfunctioning left/right turning signals can also cause serious accidents, as it is a crucial function. Yes, the vehicle is available upon request. I contacted Volvo, but they declined to fix the issue. They have published a technical bulletin regarding the problem but are not recalling the vehicles. Many other Volvo models have the same factory defect, as can be found on the internet. The technical bulletin confirms their fault. I have attached the file. No, the vehicle has not been inspected. Yes, the vehicle shows a "turn indicator malfunction" message on the main screen. This issue started around 89k miles.”
“Hi, I had a 2016 XC90 which has serious safety problems. The sunroof has a factory defect, leaking water into the car and causing failures in electronic systems and airbags. Many other owners have sued Volvo and won their cases. Additionally, the issue has been certified by the court, and there are technical bulletins published by Volvo addressing the problem. Yes. The water leak can damage entire electronic systems, such as airbags, the start-stop system, braking system, and lidar system. Once water enters any of these systems, it can lead to accidents and fires due to short circuits, posing a deadly risk. This issue can cause accidents or fires. No, but Volvo has published a bulletin, and there have been many court cases filed against Volvo since 2016. No, the vehicle has not been inspected. It's causing numerous random errors on the dashboard. This issue occurred approximately two weeks after I purchased the vehicle. link for class action [XXX] .)”
“When driving slowly to enter a parking garage, the steering wheel on the car started to feel stiff, and as I completed the turn, there was a loud snapping sound. The dashboard showed an urgent fault saying “SRS Airbag Urgent - Drive To Workshop”. I drove it to the Volvo dealer. The steering wheel was having problems turning left. When the dealer attempted to move the car, it was then unable to turn left at all. So, the steering wheel completely failed.”
Showing 6 of 56 reports. Read every report on NHTSA.gov.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.