NHTSA lists 6 safety recalls and 583 owner complaints for the 2010 Chevrolet Cobalt. Most complaints involve steering (242) and electrical system (128). The EPA rates it 25–30 mpg combined.
General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an electrical short that disables the driver side curtain air bag.
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The contact's daughter owns a 2010 Chevrolet Cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. There was no warning light illuminated. Due to the failure, extra effort was needed to steer the vehicle. The vehicle was not diagnosed or inspected for the failure. The manufacturer was notified of the failure and informed the contact that there were no recalls related to the failure for the VIN. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 14V153000 (Steering). The vehicle was not repaired. The failure mileage was approximately 54,000.”
“The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 55 MPH, the power steering and brakes became inoperable. The driver was able to coast to the side of the road. The check engine warning light was illuminated after the failure. The vehicle was towed to her parent's residence. The vehicle was serviced by an independent mechanic, who stated that the failure was due to the ignition switch. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was not covered under the recall. The contact stated that the failure was related to NHTSA Campaign Number: 14V171000 (Electrical System). The failure mileage was approximately 260,000.”
“I FOUND OUT ABOUT THE RECALL ON THE 2007-2009 ON THE CORROSION OF THE GAS LINES ON DRIVERS SIDE REAR WHEEL WHEN I TOOK MY CAR TO A CHEVY DEALER AND THEY SAID ITS THE SAME THING THATS HAPPENING TO MY CAR.AND THAT THEY ONLY DID THE RECALL ON 2007-2009 COLBALT MODELS .THE LAST COLBALT'S MADE WAS THE 2010 MODELS.WHY DIDNT THEY RECALL THEM ALSO.I TOOK IT TO ANOTHER CHEVY DEALER IN AMELIA AND THEY SAID THE SAME THING.THIS NEEDS TO BE RECALLED ASAP.ITS A SAFETY RELATED DEFECT FROM GM AND THEY KNOW IT.IF I HAVE TO I WILL GET A LAWYER AND SUE G.M. PERIOD.I CANT AFFORD TO FIX GM'S MISTAKES.THEY NEED TO COME CLEAN AND FIX THEM.IT LEAKS OUT GAS AND COULD START A FIRE OR EXPLODE WHILE I AM IN THE CAR.I DEMAND THIS TAKEN CAR OF BY GM AND STOP KICKING THE CAN DOWN THE ROAD.I WILL NOT STOP OR GIVE UP ON THIS .SENCE I WAS TOLD BY 2 DIFFRENT CHEVY DEALERSHIPS.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Cobalt XFE Coupe Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 25 | 37 | 30 | $2,100 | 296 |
| Cobalt XFE Sedan Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 25 | 37 | 30 | $2,100 | 296 |
| Cobalt Coupe Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 25 | 35 | 29 | $2,150 | 306 |
| Cobalt Sedan Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 25 | 35 | 29 | $2,150 | 306 |
| Cobalt Coupe Auto 4-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 24 | 33 | 27 | $2,300 | 329 |
| Cobalt Sedan Auto 4-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 24 | 33 | 27 | $2,300 | 329 |
| Cobalt SS Coupe Man 5-spd, 4 cyl, 2.0 L, Turbo · Front-Wheel Drive | 22 | 30 | 25 | $2,500 | 355 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
6 safety recalls as of Nov 9, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 583 complaints with NHTSA. The most-cited components are steering (242), electrical system (128), fuel/propulsion system (101). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2010 Chevrolet Cobalt at 25–30 mpg combined, depending on engine and drivetrain (7 versions rated).