2008 Chevrolet HHRRecalls, problems, MPG & safety

“While driving steering motor just stops working causing hard steering and not steer properly. You try to pull off busy highway. stop put in park shut off car then restart steering works fine just out nowhere you loose steering. its intermitten.,”

“Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600”

“FUEL LINE LEAKING IN TWO PLACES, IN THE REAR AND IN THE FRONT. COMPLETELY RUSTED OUT. MY CAR ONLY HAS 60,800 MILES ON IT. TYPE OF CAR IS A 2008 CHEVY HHR LT 2.4. GAS IS LEAKING ON THE GROUND AND A STRONG SMELL OF GAS IS EMITTED FROM THE CAR. THIS IS VERY DANGEROUS BECAUSE THE CAR COULD CATCH FIRE. I DID NOT THINK THIS WOULD HAPPEN TO MY CAR WITH SO FEW MILES ON THE CAR. I DID NOT KNOW THERE WAS A PROBLEM AND DROVE THE CAR 130 MILES AWAY FROM HOME TO MY DAD'S FUNERAL. THEN I HAD TO DRIVE IT BACK BECAUSE TH E TOW WOULD HAVE BEEN $700. THE MECHANIC WHO INSPECTED THE CAR. BUDDY LLOYD'S LAKEVIEW AUTOMOTIVE AT 4757 SANG RUN ROAD IN MCENRY, MD 21541, SAID IT WOULD COST ABOUT $2,000 TO FIX BECAUSE OF THE EXTENT OF THE CORROSION AND THE CHAEP MATERIALS USED. IN ADDITION, THE FUEL LINES ARE LOCATED UNDERNEATH OTHER MAJOR PARTS AND WOULD HAVE TO BE TAKEN OFF TO GET TO THE FUEL LINES. THE MECHANIC SAID AT ANY MOMENT IF I HIT A BUMP THAT THE GAS COULD EMPTY THE TANK AND POSSIBLY CATCH FIRE!”