2024 Ford Bronco problems

“I am the homeowner and the mother of the vehicle owner, [XXX]. I am submitting this statement about a fire involving her parked Ford Bronco in my garage. I was the only person home when I discovered the fire. At approximately 8:30 p.m. on XXX, I had just gotten out of my backyard pool when I heard a loud thump that seemed to come from around the garage. After entering the house, I heard another loud sound. When I opened the door between the house and garage, smoke came into the house. I called [XXX]. [XXX] texted me at 8:34 pm as she received a text notification that her tire pressure was low and asked me to check. I went outside through the front door to the driveway and opened the garage door. Black smoke came out. While speaking with [XXX], I obtained a garden hose and returned to the garage, where I saw active flames coming from the rear-left area of the Bronco. I used the hose on the visible flames. Firefighters arrived approximately five minutes later and took over. By then, I had extinguished most of the flames I could see. There were no injuries. The Bronco had last been driven on Saturday night, XXX. [XXX] flew to [XXX] on Sunday, XXX, and returned…”

“I notified the dealership where I bought the vehicle of the issue when it first happened in Feb 2025. I have since notified them 3 additional times and I have called Ford Motor Company, twice. The roof leaks in heavy rain while driving and when going through a car wash. The water streams inside and runs down onto the lighted vanity mirror which is connected to the electrical system of the vehicle and hits the driver in the face with water. The dealership said that they tried to reproduce the issue but couldn’t get it to leak. It’s because they aren’t using water at a high pressure and speed. I have since found that the issue is know as it is listed on the internet in multiple places.”

“I have a 2024 ford bronco 2.3 with a manual transmission 13256 miles .This Saturday we left early in the morning to go to flagstaff. We got on the freeway about to 60 and go in to 6th gear pushed clutch in and it stuck to the floor tryed pull it up and did come back up had a horrible smell and than stop moving could not put in gear and coated off the freeway shut car off let it sit for 5 minutes and started back up put in first gear did not move called road side and was told I could get it towed to the dealership and if it covered under warranty they reimburse me for the tow . I said so your leaving us stranded on the freeway with a car thet should be towed in under worenty this is not safe . 1.5 hours later the tow guy came and was towed to the [XXX] ford which I had [XXX] as my service writer she asked if maby we left the emergency brake on because of the smell than said there is an open recall that need repaired well I like to get the [XXX] to move forward or revers told her the clutch pedal went to the floor and did not come back up and in my experience the hydraulic system in the clutch went out and may have wiped out the clutch I let her know we have 3…”

“My 2024 Ford Bronco repeatedly loses power without warning while driving, including on highways, suddenly slowing to approximately 32 mph. It also fails to accelerate from traffic lights, leaving me stranded in traffic. Dashboard warnings include Powertrain Malfunction, Service AdvanceTrac, Check 4x4, and Pre-Collision Assist Unavailable. On September 30, 2026, at 9:43 PM, the vehicle lost power on the road, nearly causing a rear-end collision. I have videos documenting six incidents between September 30 and October 15, 2026. This dangerous problem has continued since May 2025. Briarwood Ford has attempted repairs seven times, including replacing the accelerator pedal twice and replacing or repairing the engine wiring harness. The vehicle has been out of service for over 60 days, yet the problem continues. Ford diagnostic data from October 15–16 identified codes P2138, U0401, U0403, and U0418. I no longer trust this vehicle to transport my family to chemotherapy appointments or allow my children to drive it. Sudden power loss in traffic creates a serious risk of injury or death. I request an immediate NHTSA safety investigation into this recurring, unresolved defect.”

“Front Differential Mount Frame Bracket Cracked Or Broken. See Ford TSB 25-2613 for detail. The Frame Bracket on my vehicle was making a loud clink/clunk sound. The broken bracket was verified by the Ford Dealer on my vehicle and is awaiting a repair. If this failure had occurred during highway speed the left front drive axel would have been placed in a bind and steering could have been lost. A roll over accident could have occurred as a result. Note: I did own a 2022 model of the same type that developed the same sound, Ford dealer verified the sound but did not find the source. The TSB 25-2613 had not been released at that time 9/2025. The 2022 was traded in and has now been resold to an unknown person who possibly has the same Frame Bracket issue.”

“There was a pot hold hole about 30 ft from a stop light. I was coming to a stop but once I hit the pot hole the breaks malfunctioned. I pumped the breaks 2-3 times. They did not reengage. This fault caused me to rear end the car in front of me at the stop light.”