2025 Ford Bronco problems

“The tubes running along the roof line according to my service report could not handle the heavy rain and was the resulted in a heavy stream of water inside my vehicle while driving. The water "backfilled" into the cabin through dome light just behind the sunglasses holder. Incident occurred on October 1, 2026 while I was driving with my two children in the vehicle. The incident was witnessed by the construction manager over seeing the construction of our home. There was so much rain inside the vehicle that it soaked my pants, my seat, the carpet, ran down the navigation screen into the cup holders and warped my dash. I wash my vehicle 2 to 3 times a week and have never had an issue with the roof leaking until driving in this storm. When I arrived home I lifted the t-top on the drivers side and there was no water in the weather stripping. I did take my vehicle to the dealer and was told this is a "common issue" with Broncos, for the tubing to wear out and that it and the electrical would be replaced. The dealer did not inspect the tubes or the electrical components in the over head compartment. They reported that several trips through the car wash did not result…”

“The contact's wife owns a 2025 Ford Bronco. Upon taking delivery of the vehicle, the door stops on both rear doors began detaching and the plastic fender components fell off while the vehicle was parked. Additionally, the rear passenger’s side window intermittently failed to roll up. The contact then received notifications of NHTSA Campaign Numbers: 26V468000 (Engine, Electrical System) and 26V403000 (Structure). The vehicle was taken to the dealer for a wiring harness recall repair; however, the dealer stated that the fix was ineffective and too complex to perform. The manufacturer was notified of the issue and confirmed that parts were available; however, the vehicle was unrepaired. The failure mileage was approximately 500.”

“I purchased a 2025 Ford Bronco Outer Banks to flat tow behind my motorhome. Ford dealership in [XXX] said the Bronco can be flat towed and I reviewed the owners [XXX] , regarding flat towing, with the dealership prior to purchase. I went to a reputable hitch installer to add a demco/Air Force one braking system. We went on a 3 month trip out west and followed the directions in the Ford owners [XXX] to flat towing. Unfortunately while being towed the car came out of neutral tow 3 times while and there is no warning system to alert us when this happens. It cannot be felt or detected in our 44 ft coach. Luckily kind strangers saw our rear tires dragging and smoking and signaled to us. The last time we were on I55 near [XXX]. This was quite frightening as this could have easily turned into an accident for us and others on the road. I was able to drive a nearby Ford dealership who assessed the damage. We were lucky that only the rear tires were badly damaged and Ford replaced them for free. It was only at this time that we learned Ford sends out bulletins to dealerships re: updates. Per the dealership a bulletin was sent out in March 2026 stating that fuses 28 and…”

“The contact owns a 2025 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, and the Forward Collision Avoidance Automatic Emergency Braking and several unknown warning lights illuminated. The vehicle was taken to the dealer several times; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 14,000.”

“Instrument Cluster screen blank on start up so vehicle does not show Speedometer, gear selection, RPM, fuel gauge, lane keeping selection, and adaptive cruise control selection/engagement. Vehicle however would start up and remain drivable. Instrument cluster screen return to its normal state of his morning after leaving vehicle turned off overnight. This occurred on one other occasion back in May 2026 shortly after purchasing the vehicle. This was only this second instance of this happening since receiving the vehicle in May 2026. I have attached a picture showing both instances. I believe there where previous Bronco models recalled for a similar issue, but don’t believe my model/VIN was included in that recall.”

“The contact owns a 2025 Ford Bronco. The contact stated while attempting to start the vehicle depressing the brake pedal, heard a clunking noise and on for second the vehicle attempts to move while in park. The contact mention he could hear clunking sound coming from the front of the vehicle. A dealer was contacted. The vehicle was taken a dealer to be diagnosed, however the diagnoses was unknown. The vehicle was not repaired. The contact was relating the failure to NHTSA Campaign Number:25V164000 (Power Train), however the VIN was not included in the recall The manufacturer was not notified on the failure, and they informed him to take the vehicle to dealer. failure mileage was 2,200.”