2017 Ford Explorer fuel/propulsion system problems

“My 2017 Ford Explorer XLT with approximately 236,000 miles has an ongoing EVAP/fuel vapor system problem that causes the vehicle to hesitate, stumble, and attempt to stall. The problem occurs most frequently after refueling and also when the fuel level is low. The check-engine light comes on repeatedly, and despite numerous repair attempts, the issue has not been corrected. Repairs and parts replaced have included the purge valve, EVAP-related sensor(s), charcoal canister(s), and associated tubing. Significant money has been spent diagnosing and repairing this condition, but the symptoms continue. After filling the fuel tank, the engine may run rough, hesitate, lose power, and attempt to stall. This creates a safety concern because the vehicle can unexpectedly lose power or stall while driving, entering traffic, slowing for intersections, or operating in other traffic situations. The condition has persisted despite replacement of multiple EVAP system components. Based on the repeated failures and inability to permanently correct the issue, I believe this may indicate a defect affecting other vehicles of the same model year. I am requesting that this issue be…”

“Vehicle experienced white exhaust smoke due to oil entering the exhaust system, caused by turbocharger failure. This led to contamination and failure of all O2 sensors, requiring full replacement, along with replacement of both turbochargers. The radiator also failed and had to be replaced. This appears to be a cascading mechanical failure affecting multiple major systems, including the engine, fuel/propulsion system, and electrical components, rather than normal wear and tear. The failure rendered the vehicle inoperable, leaving me without transportation during a period of financial hardship. The severity and extent of repairs raise concern about a potential broader defect. This also created a safety concern due to excessive exhaust smoke and reduced vehicle reliability while in operation.”

“1 WATERPUMP FAILED AND LEAKED WATER INTO MY OIL AND BLEW MY ENGINE. THERE WAS NO WARNING. MY CAR HAD NO POWER AND I COULD NOT DRIVE. I WAS ON THE SIDE OF THE ROAD. THE WATERPUMP IS NOT A RECALL BUT THERE ARE ALOT OF PEOPLE WITH THE SAME ISSUE ON THE SAME MODEL . THE ENGINE WAS REPLACED AT MY EXPENSE. 2. PILLAR/TRIM RECALL IS NOT FIXED AND WATER IS GETTING INTO THE INSIDE OF MY CAR AND SHORTING OUT MY PLUGS AND WIRES AND STAHLING MY CAR WHEN IT RAINS. NO WARNING SIGNS OR LIGHTS FOR EITHER PROBLEM. THE CAR HAS BEEN INSPECTED FOR THE RECAL . I WAS JUST TOLD FORD HAS NOT PROVIDED A REPAIR SOLUTION FOR THE PROBLEM. THIS RECAL IS FROM 1/19/2024”

“It is known that for the specific year make and model that the water pump goes out around 100,000 miles. This water pump was built as an internal water pump, which is not typical for most cars. in order to fix this part, the engine has to be taken out and lots of parts have to be disassembled Just to get to it. The part Itself is fairly cheap, but the labor cost thousands of dollars due to where it is located. Ford knowingly built this car and put that pump where it is at and therefore should be reliable to pay the cost when it is so common that this part goes out around 100,000 miles. if it is a known issue that occurs on these models frequently then it should become a recall because a failing water pump can cause significant issues within the engine and make the vehicle in operable.”

“I am submitting this complaint regarding a recurring turbocharger issue in my 2017 Ford Explorer Sport (VIN: [XXX] ). In April 2024, I was forced to replace the turbocharger system at a cost of approximately $2,500. Despite the repair, my vehicle continues to have serious performance issues. Most recently, the check engine light returned, and a diagnostic scan from O’Reilly Auto Parts showed error code P219A – Bank 1 Air/Fuel Ratio Imbalance. This code indicates that the engine is still not functioning correctly—pointing to a likely underlying or unresolved defect. During the initial failure, oil leaked extensively into the engine bay and burned off in thick white smoke while I was driving. It was a serious safety concern, and the cause was consistent with Ford’s existing recall for this engine (NHTSA Campaign Number: 16V925000), which was limited to the Police Interceptor Utility model despite the civilian Sport version using the same 3.5L EcoBoost V6 engine and components. It is extremely concerning that my vehicle—outside of the official recall range—suffered the same turbo failure and now continues to show problems even after a costly repair. Either the…”

“Water pump failure, causing over heating in vehicle , not even 100,000miles. Causing to leave us stranded on the road. Apparently there's a lot of complains for this pump causing issues. Please look into this and start a recall process.”