2024 Ford F-150 problems

“URGENT SAFETY COMPLAINT – 2024 FORD F-150 TREMOR Since May 2026, my 2024 Ford F-150 Tremor has repeatedly experienced a dangerous transmission gear-shifting malfunction. Without warning, the gear selector locks, preventing the vehicle from engaging Drive, Reverse, or Park, leaving it immobilized. This has occurred in parking garages, blocking entrances and exits, and on interstate highways after stopping in traffic. The vehicle can become stranded in active traffic with no reliable way to move it to safety. This creates an extreme collision risk, potentially resulting in serious injuries or fatalities involving myself, my family, and other motorists. This is not an isolated concern. Ford issued Technical Service Bulletin 25-2276 addressing gear shift module failures in 2021–2025 F-150 trucks, including inability to shift into Park or out of gear. NHTSA complaints 11745086 and 11751717 describe similar failures in 2024 F-150 vehicles. Despite the recurring safety hazard, Ford has refused to repair my vehicle without charging me, citing expiration of the 3-year/36,000-mile warranty due to mileage. A potentially life-threatening safety defect should not be…”

“The contact owns a 2024 Ford F-150. The contact stated that following an unsuccessful Over-the-Air (OTA) software update, the display screen and instrument panel were constantly rebooting, with a loss of functionality for several electrical features. The vehicle was taken to a dealer, where technicians associated the failure with NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting). After several service repairs and the inclusion of a field service engineer, the vehicle remained unrepaired and had been with the dealer for over two months. The manufacturer was notified of the failure and provided the contact with a case number. The contact was not provided any status updates because the master technicians were on extended leave. The failure mileage was approximately 25,000.”

“Re: Recurring Knock Sensor Failure — 2024 Ford F-150 STX (2.7L) I am writing to document a recurring mechanical issue with my 2024 Ford F-150 STX, 2.7L, currently at approximately 30,900 miles, purchased new. First Incident (late XXX): While driving, the check engine light illuminated, indicating a knock sensor fault. I brought the vehicle to Ted Britt Ford in [XXX], where it remained for five days for sensor replacement. I requested a loaner vehicle, which the dealership stated was unavailable, requiring me to rent a replacement vehicle at my own expense. Second Incident (XXX): Following a period of heavy rainfall, the check engine light returned with an identical knock sensor fault. The vehicle was again taken to the same dealership and held for five days for repair. When I again requested a loaner, I was informed one could not be provided because the vehicle was not originally purchased at that dealership. Rental Costs: Across both repairs, I have incurred rental vehicle expenses for a combined 10 days due to the dealership's lack of loaner availability. Suspected Root Cause: Based on the pattern of failures — particularly the correlation with heavy rain — I…”

“While driving in Sport mode on an interstate, during descending downhill, the transmission started down shifting. At that time near the bottom of the hill was standing water on an area. It was suddenly like hitting the brakes & I hydroplaned, but luckily I never touched the brakes. The down shifting at the same time as hitting the water caused the vehicle to loose control of the road. Luckily I regained control by steering and did not wreck. There should be a safety warning on this issue or a correction in the vehicle down shifting”

“Purchased new vehicle May 2024 primarily for towing my recreational vehicle (2024 Ford F150 Pickup). June 2024 took vehicle to dealership indicating that I was intermittently getting a "Trailer Disconnect" warning while driving (loss of trailer brakes, lights etc.). Dealer indicated no issue found. Subsequently returned to dealership on 6 other occasions over 2 years after continuing to experience the failure. Replaced 7 pin connector on trailer and dealer has replaced the 7 pin on vehicle and Trailer Control Module (TCM) but problem persists. Early 2026 dealership performed a recall on TCM software - did not resolve the issue (vehicle intermittently indicates the trailer is disconnected while driving or manually activating the trailer brakes). Issue seems to occur typical on startup after several hours of driving with a trailer (heat related), and every time activate the trailer brakes manually. I get a "Trailer Disconnect" warning by activating the manual trailer brake even without a trailer attached. Working with Ford Customer Service Team and the dealership for 7 days, no solution was discovered. The dealership indicated (in writing) that it is normal…”

“While traveling at cruising speed (70 MPH) on Interstate 95 South, the vehicle suffered a catastrophic electrical and mechanical failure, resulting in an immediate engine stall. The vehicle lost all propulsion. Due to the sudden loss of power, the vehicle could not safely clear the active lanes of traffic, coasting to a stop near an exit ramp and dangerously blocking highway traffic.Upon attempting to restart the vehicle to move it out of harm's way, the vehicle emitted a rapid clicking noise and again stalled out. Because this vehicle utilizes an electronic shift-by-wire system, the total power failure permanently locked the transmission into "Park." The vehicle could not be shifted into "Neutral" or "Drive" to be pushed safely off the road.This total vehicle failure created an immediate, life-threatening hazard for the occupants and surrounding motorists on a high-speed interstate, requiring emergency police intervention to manage traffic until a flatbed tow truck arrived.”