2018 Honda Ridgeline problems

“From researching this, my Honda 2018 Ridgeline is having a problem with the Keyless Access/TPMS Control Unit, causing the vehicle security alarm to go off when the vehicle is idol which could result in a dead battery if not attended. Honda referenced this manufacturing defect in its Service Bulletin 21-055 dated XXX. I have attached a copy of the Service Bulletin. Since this problem is affecting a number of different Honda models, my question is if this admitted manufacting problem is under consideration for a recall by NHTSA. Honda dealers are changing upwards of $800-$1,000 to replace and program the unit. Thank you. [XXX], [XXX] or [XXX].”

“The contact owns a 2018 Honda Ridgeline The contact received notification of NHTSA Campaign Numbers: 23V858000 (FUEL SYSTEM, GASOLINE) and 22V867000 (BACK OVER PREVENTION) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available”

“The vehicle was being driven under normal highway conditions while towing a boat within the vehicle's rated towing capacity. The driver observed the oil pressure warning light illuminate and continued driving normally for approximately 20-30 minutes, at which point the engine lost power and stalled. The vehicle would not restart. Upon inspection, engine oil and transmission fluid were both found at proper levels with no signs of contamination, and the crankshaft was confirmed to be fully seized (will not rotate by hand). There was no prior knocking noise or warning sign before the oil light illuminated. The safety of the driver was put at risk due to the possibility the bearings could eject from the engine. The engine seizure has been confirmed by Right Honda, 7875 E Frank Lloyd Wright Blvd., Scottsdale, AZ 85254. The vehicle was inspected by them and they produced a diagnostic.”

“I went to fill my vehicle with gasoline on 02/06/2025. The 2018 Honda Ridgeline has a capless fuel system to enter fuel into the vehicle and there are two flaps that the gasoline nozzle is required to open. It repeatedly attempted to insert the nozzle and the first flap would not move. I pushed harder, and the first flap broke. I still could not insert the nozzle to get gasoline into my vehicle. I then observed a block of ice preventing the nozzle from accessing the second flap. I could not remove the ice to put gas in my vehicle. On 02/07/2025, the temperature rose above freezing and I was able to mop out the water from the area, however my capless system was broken at this time. I brought it to the local Honda dealership and they were able to repair the damaged component, however charged me for this repair as they contended there were no recalls on this issue and the vehicle is out of warranty. I went on the internet and found in several consumer forums that people have cited this to be an issue with the Ridgeline and other Honda vehicles. I am unclear how Honda could manufacture a vehicle component that allows water to collect at the entrance to the gas tank…”

“The referenced Recall for my Honda Ridgeline indicates that the fuel pump is suspect for an inadequate impeller and a possible safety problem. I have been awaiting this replacement part at least 8 months and the original recall has a date of December 18, 2023 which is over a year since identified. I have visited the dealership several times over the last six months and have been assured that I am on the "list" to receive a new fuel pump. The service department informed me on January 7, 2025 that they still have not received the fuel pump from you. The latest recall notice informed me pumps are available, but as you see in the previous paragraph I am not able to get the pump at present. Please expedite the delivery of the new improved fuel pump to the Honda dealership in Maui (Island Honda, 110 Hana Hwy, Kahului, HI 96732) to resolve this long overdue corrective action for my Honda Ridgeline truck”

“My truck has a persistent driveline vibration, judder, and hesitation issue. This condition creates sudden, unexpected driveline surge and power-delivery hesitation, which poses a distinct safety concern. Honda TSB 23-078 (Warranty Extension for Torque Converter), acknowledges a manufacturing defect in the torque converter lock-up piston. Moreover, failure of the torque converter may also compromise my truck's transmission and cause a significant safety risk to myself as well as other vehicles and persons in them. The problems with my truck have been documented by local dealer Island Honda during a recent recent service visit. The dealer invoice explicitly states: "While driving recorded snapshot when judder happened, verified spike seen on data snapshot." Despite the technician capturing real-time diagnostic evidence of the torque converter lock-up clutch slipping and surging, the dealership refused to perform the warranty repair because the vehicle’s computer had not yet stored Diagnostic Trouble Code (DTC) P0741. The condition of my vehicle poses an immediate highway safety hazard. The severe juddering introduces unexpected powertrain vibration, distracting…”