2025 Kia Carnival Hybrid problems

“My 2025 Kia Carnival Hybrid was purchased new in January 2025. The problem began almost immediately, with the vehicle first presented to an authorized Kia dealer for this condition at only 810 miles. The vehicle repeatedly and unpredictably enters reduced-power or “limp mode,” causing a sudden loss of normal acceleration and limiting it to approximately 35 mph. This creates a serious safety risk on highways, while merging, crossing intersections, or whenever acceleration is needed to respond to traffic. Equally concerning, the vehicle does not consistently display a warning or retain a hard diagnostic error code when the loss of power occurs. Sometimes a check-engine light or “Check Hybrid System - Stop Safely” message appears, but at other times the vehicle enters limp mode with no warning. After turning the vehicle off and restarting it, normal operation may return and the error disappears, leaving the dealer unable to retrieve a stored code showing what occurred. The vehicle has been presented to an authorized Kia dealer for this recurring issue at least five times. In August 2026, it remained in limp mode and had to be towed to the dealer. We were initially…”

“In May 2026, after driving through a heavy rainstorm on the highway, the car suddenly cut off cruise control and showed multiple warning lights (for most, if not all assistance systems) and an error message that was some version of "check hybrid system." When searching the code it seemed to be related to an electrical short in the hybrid system. I had no electric power to the engine, but the gas functionality still sort of worked, so I could drive, but there was a 2-3 second delay between pushing the gas pedal and getting any acceleration, and said acceleration was minimal. This occurred at 70+ mph on a busy highway, so the sudden lack of acceleration and control was alarming and put us and the cars around us at risk due to sudden speed change. When we pulled into a safe stop and turned the car off for a few minutes and then back on, the error messages were gone and hybrid system seemed functional again. The check engine light remained, but turned off after the next short trip. There had been no warnings, lights, or symptoms of any issues at any point prior to this occurring. The car was not seen at the time due to being on vacation and not near any Kia…”

“On random occasions, car will display "check hybrid system" and go into limp mode (limiting speed significantly) check engine, oil, and battery lights also illuminate. Had car serviced twice by dealership who cannot replicate the error, nor can they find any engine codes stored. However, this incident keeps occurring. Planning on having the car serviced again and not picking it up until it's figured out, but also wanted to report this incidence as I have seen several posts with other people complaining of the same issue. Concern is for if this happens randomly at freeway speeds and becomes a serious road hazard.”

“Within 5 minutes of driving, the car stopped accelerating. Check hybrid system alert appeared one minute later. Car stalled out within approximately 1-2 minutes after warning light appeared. No other warning lights were present prior. This is a 2025 new Kia Carnival Hybrid. I was stranded on the side of a 55mph road. The first time the police helped me roll it off the road. The second time it couldn’t be pushed even though it appeared to be in neutral. The car dies but the accessory functions will not turn off. We have to unplug the battery each time. This car could die ANYWHERE leaving you stranded in a very dangerous situation. There is very little warning. This is extremely hazardous. This is the SECOND time this has occurred with a combined total of 5 hours waiting for tow trucks and countless hours contacting Kia. Kia kept the car for two weeks and recharged the battery. That’s it. It died again within 24 hours of being returned to us. This is UNSAFE and unreliable.”

“On five separate occasions, while turning onto a high-speed roadway and attempting to accelerate to the flow of traffic, the vehicle suddenly lost the ability to accelerate. Despite pressing the accelerator, the vehicle would not exceed approximately 35 mph and then began to decelerate. During both incidents, a "Check Hybrid System" warning appeared, and I was forced to quickly pull over to the side of the high-speed road. The vehicle would only return to normal operation after it was turned off and restarted. This loss of power while merging into traffic created an extremely dangerous situation. Having three young children in the vehicle made the experience especially frightening, and I no longer have confidence that the vehicle can be relied upon to operate safely. Because this defect affects the vehicle's ability to accelerate safely in traffic, I am deeply concerned that it could result in a serious collision if it happens again. I took it into the dealership and the service center experienced the same issue. They thought they had resolved the issue and that it was a "one off" occurrence but it happened to me again just 3 weeks after the attempted repair.…”

“This complaint is a follow up to complaint #XXX. I took the car in to Dennis Eakin Kia in [XXX] to repair what caused the car to go into Limp Mode after slamming on the brakes. The dealership did a deep scan of the hybrid control and power train control module for historical or iintermittent codes. They could find none because the car apparently does not save them after the ignition is turned off. They are trashed. They also tried 4 times to re-create the event by slamming on the brakes, but were unable to re create it. They returned the car to me without fixing it. This is another deep -imbedded safety hazard of this car that a well-documented safety hazard from many drivers cannot be fixed because the car trashes any evidence of these incidences. This car is a clear danger to drivers, a danger that can only be fixed through a recall to get them off the road until a fix is executed by the manufacturer.”