2022 Kia NiroRecalls, problems, MPG & safety

“On XXX, After I attempted to plug my car into my home charging outlet at 240V, less than 20 minutes later I received an alert that my battery was at 0%. After unplugging the car, waiting for 30 minutes and plugging it back into the out, my car was unable to see the charging outlet or the 40A cable plugged into the port. Unplugged car again and after talking to remote mechanic, came to decision to take car to AAA repair shop for troubleshooting. Once at the AAA repair shop in [XXX], was advised to take my car to a Kia dealership, as a module was nonfunctional. Brought car to Beyer Kia in [XXX], who held onto my car for two months before making a diagnosis that my car was struck by lightning via a Field Technical Engineer, though the DTC codes stated otherwise: C180287, C161487, C16b487, C161487, C161487, C182D00. All codes noted are internal Controller Area Network Bus Communication Timeouts between internal modules, not power surge or electrical strike. C161487 - registered three times: Internal network timed out because VCU abruptly went offline or lost power. With it registering 3 times confirms ongoing hardware/power supply struggle inside car's computers,…”

“I purchased this used 2022 Kia Niro EV on August 19, 2023, with approximately 3,042 miles. On December 22, 2023, at 24,086 miles, a Kia of Valencia service record documented a kicking/knocking sensation when releasing the brake. The cause was not identified. On August 22, 2024, another service record documented a rear seat belt retraction concern. I cannot confirm whether these earlier problems share the same cause as the later motor issue. On March 31, 2026, at approximately 139,071 miles, Kia of Valencia confirmed a rattling noise from the gear driver motor and recommended replacement. The estimated repair cost was approximately $4,800. I paid a $250 diagnostic fee but could not afford the repair. I contacted Kia America to request goodwill assistance, but the motor was not replaced. On September 9, 2026, while driving on a freeway in heavy traffic, the vehicle repeatedly stopped and moved again, accompanied by extremely loud knocking, rattling, and banging. The vehicle shook, and no warning lights or messages appeared beforehand. I carefully exited the freeway and stopped the vehicle. After bringing it home, I noticed liquid underneath, but could not…”

“2022 Kia Niro EX Premium Hybrid was sold as Kia Certified Pre-Owned on August 12 2026 with an active check engine light present at time of purchase. Dealer Calavan Kia West in Lithia Springs GA represented the vehicle as passing a 165-point CPO inspection. Dealer attributed the light to a gas cap issue and cleared the code to complete the sale. Six days later approximately August 18 2026 the check engine light returned. Dealer attempted one repair which failed. As of August 25 2026 the defect remains active and undiagnosed. On a hybrid vehicle an undiagnosed engine or propulsion system fault represents a potential safety concern. The CPO certification process failed to identify this defect prior to sale.””