NHTSA lists 3 safety recalls and 68 owner complaints for the 2005 Kia Sportage. Most complaints involve air bags (12) and electrical system (8). The EPA rates it 19–22 mpg combined.
ON CERTAIN SPORT UTILITY VEHICLES, THE PARKING BRAKE LEVER RATCHET PAWL WAS NOT PROPERLY MANUFACTURED AND MY DAMAGE THE TEETH OF THE PARKING BRAKE LEVER RATCHET. DAMAGED PARKING BRAKE LEVER RATCHET TEETH MAY PREVENT THE PARKING BRAKE FROM ENGAGING OR MAY ALLOW THE PARKING BRAKE TO RELEASE AFTER IT HAS BEEN ENGAGED.
ON CERTAIN SPORT UTILITY VEHICLES, FUEL MAY LEAK FROM THE O-RING INTO THE INTERNAL VAPOR CHAMBER LOCATED IN THE FUEL TANK AT FULL TANK CONDITIONS.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ELECTRONIC STABILITY PROGRAM (ESP), THE YAW RATE SENSOR MAY BECOME TOO SENSITIVE AND MAY RECALIBRATE INACCURATELY. WHILE DRIVING THE ESP PROGRAM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKE AT ONE OF THE WHEELS TO BE INAPPROPRIATELY.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Complaints for each Sportage model year we’ve synced.
| Model year | NHTSA complaints |
|---|---|
| 1996 | 57 |
| 1997 | 187 |
| 1998 | 303 |
| 1999 | 284 |
| 2000 | 304 |
| 2001 | 228 |
| 2002 | 237 |
| 2005 | 68 |
| 2006 | 111 |
| 2007 | 77 |
| 2008 | 98 |
| 2009 | 80 |
| 2010 | 20 |
| 2011 | 181 |
| 2012 | 392 |
| 2013 | 381 |
| 2014 | 125 |
| 2015 | 146 |
| 2016 | 134 |
| 2017 | 404 |
| 2018 | 165 |
| 2019 | 71 |
| 2020 | 166 |
| 2021 | 54 |
| 2022 | 47 |
| 2023 | 194 |
| 2024 | 75 |
| 2025 | 55 |
| 2026 | 30 |
“TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 40 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (KIA OF MCCOMB IN MCCOMB, MS, 601-250-1005) WHERE IT WAS DIAGNOSED THAT THE SEAT BELT WAS FAULTY. THE DEALER REFERRED THE CONTACT TO NHTSA. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT ALSO RECEIVED THE SETTLEMENT NOTICE FROM TK HOLDINGS, INC. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 128,000.”
“TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL BURNING ODOR AND SHE OBSERVED SMOKE EMITTING FROM THE VEHICLE. THE CONTACT STATED THAT A WIRE INSIDE THE VEHICLE ON THE PASSENGER SIDE CAUGHT FIRE. THE CONTACT EXTINGUISHED THE FIRE WITH HER HANDS AND DISCONNECTED THE WIRE. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE SHE WAS ADVISED THAT THE BLOWER RESISTOR WAS THE CAUSE OF THE FAILURE AND HE SEPARATED THE WIRES TO REMEDY THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 54,000.”
“THE CLUTCH WENT OUT ON OUR KIA SPORTAGE AND WHEN WE HAD IT AT THE AUTO MECHANIC, HE TOLD US, THE FRAME WAS SO RUSTY IT WAS A MAJOR SAFETY ISSUE. WE WERE ALARMED TO HEAR THIS CONSIDERING WE USED THIS CAR TO TRANSPORT OUR GRANDCHILDREN SOMETIMES AND THOUGHT ABOUT WOULD COULD HAVE HAPPENED. CURRENTLY WE DO NOT EVEN WANT THE CLUTCH REPAIRED AS WE HAVE BEEN TOLD NOT TO CONSIDER EVEN DRIVING IT UNLESS THE FRAME SUB RAILS/FLOOR ARE REPLACED. I HAVE SINCE READ OTHER REVIEWS AND HAVE FOUND SIMILAR ALARMING CONCERNS. KIA SHOULD ADDRESS THIS HUGE SAFETY ISSUE. WE CANNOT DRIVE THE CAR, CANNOT FIX THE CLUTCH, SO IT IS JUST SITTING AT THE MECHANICS. WHAT DO WE DO, JUST JUNK THE CAR? WHAT A COST INFRINGEMENT. WE WILL NEVER PURCHASE ANOTHER KIA, NOR WILL PEOPLE THAT WE INFORM OF THIS ISSUE. I SHUDDER WHEN I THINK ABOUT WHAT COULD HAVE HAPPENED, ESPECIALLY DRIVING ON THE HIGHWAY. PLEASE ADVISE...”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Sportage 2WD Auto 4-spd, 4 cyl, 2.0 L · Front-Wheel Drive | 19 | 25 | 22 | $2,750 | 404 |
| Sportage 2WD Man 5-spd, 4 cyl, 2.0 L · Front-Wheel Drive | 20 | 25 | 22 | $2,750 | 404 |
| Sportage 4WD Man 5-spd, 4 cyl, 2.0 L · 4-Wheel or All-Wheel Drive | 19 | 24 | 21 | $2,850 | 423 |
| Sportage 2WD Auto 4-spd, 6 cyl, 2.7 L · Front-Wheel Drive | 17 | 23 | 20 | $3,000 | 444 |
| Sportage 4WD Auto 4-spd, 6 cyl, 2.7 L · 4-Wheel or All-Wheel Drive | 17 | 21 | 19 | $3,150 | 468 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
3 safety recalls as of Nov 13, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 68 complaints with NHTSA. The most-cited components are air bags (12), electrical system (8), structure (8). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2005 Kia Sportage at 19–22 mpg combined, depending on engine and drivetrain (5 versions rated).