NHTSA lists 4 safety recalls and 32 owner complaints for the 2002 Lincoln Navigator. Most complaints involve vehicle speed control (7) and air bags (7). The EPA rates it 12–13 mpg combined.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Complaints for each Navigator model year we’ve synced.
| Model year | NHTSA complaints |
|---|---|
| 1998 | 201 |
| 1999 | 138 |
| 2000 | 133 |
| 2001 | 92 |
| 2002 | 32 |
| 2003 | 127 |
| 2004 | 86 |
| 2005 | 48 |
| 2006 | 60 |
| 2007 | 45 |
| 2008 | 30 |
| 2009 | 10 |
| 2010 | 16 |
| 2011 | 9 |
| 2012 | 12 |
| 2013 | 14 |
| 2014 | 17 |
| 2015 | 21 |
| 2016 | 25 |
| 2017 | 32 |
| 2018 | 52 |
| 2019 | 85 |
| 2020 | 32 |
| 2021 | 34 |
| 2022 | 21 |
| 2023 | 7 |
| 2024 | 16 |
| 2025 | 14 |
| 2026 | 0 |
| 2027 | 0 |
“TL* THE CONTACT OWNS A 2002 LINCOLN NAVIGATOR. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FUEL GAUGE DID NOT INDICATE THE ACCURATE AMOUNT OF FUEL IN THE VEHICLE. IN ADDITION, THE HAZARD LIGHTS FAILED TO ILLUMINATE PROPERLY AND THE SPEED CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE ENGINE FAILED AND THE FUEL PUMP AND FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.”
“TL* THE CONTACT OWNS A 2002 LINCOLN NAVIGATOR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE DRIVER'S SIDE REAR PASSENGER'S AIR BAG DEPLOYED INDEPENDENTLY WITHOUT WARNING. ALSO, THE CONTACT MENTIONED THAT THERE WAS AN EXPLOSION UNDERNEATH THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.”
“I HAD THE SPARK PLUG BLOW OUT OF THE HOLE CAUSED CAR TO RUN ON LESS COMPRESSION AND IT IS VERY COSTLY TO FIX MECHANIC INFORMED THIS VEHICLE IS KNOWN FOR THIS. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Navigator 2WD Auto 4-spd, 8 cyl, 5.4 L · Rear-Wheel Drive | 11 | 15 | 13 | $5,950 | 684 |
| Navigator 4WD Auto 4-spd, 8 cyl, 5.4 L · 4-Wheel or All-Wheel Drive | 10 | 15 | 12 | $6,450 | 741 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Nov 8, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 32 complaints with NHTSA. The most-cited components are vehicle speed control (7), air bags (7), engine and engine cooling (7). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2002 Lincoln Navigator at 12–13 mpg combined, depending on engine and drivetrain (2 versions rated).