NHTSA lists 2 safety recalls and 315 owner complaints for the 1996 Saturn SL. Most complaints involve engine and engine cooling (62) and service brakes, hydraulic (42). The EPA rates it 25–29 mpg combined.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“TL*THE CONTACT OWNS A 1996 SATURN SL. THE VEHICLE WAS LEAKING OIL ON THE GROUND AND ALL OVER THE COOLING SYSTEM. THE TEMPERATURE GAUGE KEPT FLUCTUATING INTO THE RED ZONE. THE CHECK ENGINE SOON LIGHT ILLUMINATED INTERMITTENTLY AND THE VEHICLE BEGAN TO DRIVE DIFFERENTLY. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS A CRACKED CYLINDER HEAD. THE COST TO REPAIR THE VEHICLE WAS $2,257. THE CONTACT RECEIVED A SPECIAL POLICY LETTER FROM SATURN IN JUNE OF 1999 CONCERNING A CRACKED CYLINDER HEAD. THE LETTER STATED THAT THERE WAS NO RECALL CAMPAIGN AND IT WAS UNNECESSARY TO TAKE THE VEHICLE TO A DEALER. THE CURRENT MILEAGE WAS 73,000 AND FAILURE MILEAGE WAS 63,000. UPDATED 05/06/08. *LJ UPDATED 05/06/08. *JB”
“TL* - THE CONTACT WOULD LIKE TO MAKE A COMPLAINT CONCERNING THE BRAKES ON 1996 SATURN SL2. THE CONTACT STATED THAT SHE WAS DRIVING 35 MPH WHEN SHE WAS CUT OFF BY ANOTHER CAR. SHE THEN APPLIED THE BRAKE PEDAL WHICH GAVE NO RESISTANCE. THE CONTACT STATED THAT BEFORE BEING CUT OFF THE BRAKES DID WORK. THE CONTACT STATED THAT THE CAR FINALLY STOPPED AFTER SHE PUMPED THE BRAKES. THE CONTACT CONTINUED TO DRIVE AT APPROXIMATELY 5 MPH UNTIL SHE REACHED HER DESTINATION AND HAD THE CAR TOWED TO A SATURN DEALERSHIP. THE CONTACT STATED THAT THIS BRAKE FAILURE OCCURRED APPROXIMATELY DECEMBER 5, 2006. THE CONTACT STATED THAT IT WAS A NICE DAY, AND THAT THE WEATHER WAS NOT A FACTOR. THE CONTACT PULLED MUSCLES IN HER BODY, AND WAS CURRENTLY ON MUSCLE RELAXANTS. THE CONTACT ASKED THE SATURN DEALER FOR THE DAMAGED PARTS AND WAS TOLD THAT THE PARTS WERE THROWN AWAY. THE CONTACT ALSO STATED THAT SHE HAS HAD PROBLEMS WITH THE BRAKES PULSATING AND GOING ALL THE WAY DOWN TO THE FLOOR SINCE SHE PURCHASED THE CAR. THE CONTACT STATED HAD BRAKE WORK DONE IN 2001 AT 36,000 MILES, THE BRAKE CALIPERS HAD FAILED. THE CONTACT WAS REFERRED TO NHTSA BY THE RHODE ISLAND STATE ATTORNEY'S OFFICE. *AK”
“FIRST PROBLEM IS DOOR CHIMES WITH KEY OUT OF IGNITION. SECOND PROBLEM IS DOME LIGHT STAYS ON IN FRONT OR REAR POSITION WITH ALL DOORS SHUT. THIRD PROBLEM IS NO POWER AT ALL TO THE CAB WHEN I TRIED TO START CAR, AND THEN MY PASSENGER OPENED AND SHUT THE PASSENGER FRONT DOOR AND THE POWER CAME BACK ON AND I WAS ABLE TO START THE CAR. I HAD TO RESET THE CLOCK AND RADIO.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| SL Man 5-spd, 4 cyl, 1.9 L, (FFS) (MPFI), SIL · Front-Wheel Drive | 25 | 36 | 29 | $2,150 | 306 |
| SL Auto 4-spd, 4 cyl, 1.9 L, (FFS) (MPFI), CLKUP · Front-Wheel Drive | 23 | 33 | 27 | $2,300 | 329 |
| SL Man 5-spd, 4 cyl, 1.9 L, (FFS) (MPFI), SIL · Front-Wheel Drive | 22 | 32 | 26 | $2,400 | 342 |
| SL Auto 4-spd, 4 cyl, 1.9 L, (FFS) (MPFI), CLKUP · Front-Wheel Drive | 21 | 31 | 25 | $2,500 | 355 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
2 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 315 complaints with NHTSA. The most-cited components are engine and engine cooling (62), service brakes, hydraulic (42), electrical system (40). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1996 Saturn SL at 25–29 mpg combined, depending on engine and drivetrain (4 versions rated).