NHTSA lists 3 safety recalls and 256 owner complaints for the 1997 Saturn SL. Most complaints involve engine and engine cooling (41) and electrical system (40). The EPA rates it 25–28 mpg combined.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
VEHICLE DESCRIPTION: PASSSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH SUSPECT COLD WELDS ON THE RIGHT SIDE IN THE TUNNEL AREA OF THE FLOOR PAN. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ANCHORAGE."
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“SEVERE RUST OUT OF THE SUSPENSION SUB-FRAME (ENGINE CRADLE) ALONG THE LEFT SIDE, PARTICULARLY AT THE LOWER CONTROL ARM MOUNT POCKET. THIS CONDITION WAS CAUGHT BEFORE THE LEFT FRONT LOWER CONTROL ARM BROKE LOOSE DUE TO THE RUSTED SUB-FRAME. RUST CONDITION WAS CONFINED TO THE LEFT SIDE OF THE SUB-FRAME WITH NO APPARENT ISSUE WITH THE RIGHT SIDE OR CROSS BEAMS. BROUGHT TO SATURN'S ATTENTION BUT CONCERN WAS DENIED AS THE "VEHICLE IS OUT OF WARRANTY". SATURN NEVER ADDRESSED THE ISSUE THAT THE SUB-FRAME IS A COMPONENT THAT SHOULD LAST THE LIFETIME OF THE VEHICLE. *TR”
“TL* THE CONTACT OWNS A 1997 SATURN SL. THE CONTACT STATED THAT THE KEY FELL OUT OF THE IGNITION AND THE VEHICLE CONTINUED TO RUN. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE.”
“TL* THE CONTACT OWNS A 1997 SATURN SL. THE CONTACT STATED THAT HE WAS REVERSING FROM A RESIDENTIAL DRIVEWAY WHEN HE SHIFTED TO FIRST GEAR AND THE SHIFTER CABLE BECAME DETACHED FROM THE SHIFTER LEVER. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THEY HAD TO REPLACE TWO SHIFTER CABLES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 127,000. UPDATED 7/26/12 *CN THE CONSUMER STATED THE ROOT OF THE PROBLEM WAS THE FAILURE OF A SMALL PLASTIC BUSHING USED TO JOIN THE SHIFTING LEVER TO THE SHIFTING CABLE IN A MANUAL TRANSMISSION. WHEN THE BUSHING FAILED, THE SHIFTING CABLE FELL OFF THE SHIFTING LEVER WHICH LEFT THE CONSUMER UNABLE TO SHIFT GEARS. THE CONSUMER STATED THE FAILURE HAPPENED WHILE HE WAS STOPPED IN HIS DRIVEWAY. THE DEALER WOULD NOT REPLACE THE BROKEN BUSHING, BUT INSTEAD REPLACED THE ENTIRE CABLE AS WELL AS AN ADJOINING CABLE. UPDATED 08/06/12”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| SL Man 5-spd, 4 cyl, 1.9 L, SOHC (FFS) (MPFI) · Front-Wheel Drive | 24 | 36 | 28 | $2,200 | 317 |
| SL Auto 4-spd, 4 cyl, 1.9 L, SOHC (FFS) (MPFI) · Front-Wheel Drive | 23 | 33 | 27 | $2,300 | 329 |
| SL Man 5-spd, 4 cyl, 1.9 L, DOHC (FFS) (MPFI) · Front-Wheel Drive | 23 | 33 | 27 | $2,300 | 329 |
| SL Auto 4-spd, 4 cyl, 1.9 L, DOHC (FFS) (MPFI) · Front-Wheel Drive | 21 | 31 | 25 | $2,500 | 355 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
3 safety recalls as of Nov 9, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 256 complaints with NHTSA. The most-cited components are engine and engine cooling (41), electrical system (40), power train (24). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1997 Saturn SL at 25–28 mpg combined, depending on engine and drivetrain (4 versions rated).