2018 Subaru CrosstrekRecalls, problems, MPG & safety

“The front windshield spontaneously developed a crack about 5 inches long which later suddenly increased to about 15 inches in length. It is our understanding that this problem has occurred in the windshields of other Subaru models. The internet states that Subaru windshields have had a tendency to crack without impact due to the windshield's angle or thinness to accommodate Eyesight technology.”

“On 06/26/26, while traveling at highway speeds, the vehicle suffered a sudden, catastrophic loss of motive power in active traffic due to a blown out/melted Cylinder 4 ignition coil. This unexpected engine failure forced raw fuel into the exhaust system, causing an immediate internal thermal meltdown of the catalytic converter, rendering the vehicle entirely undriveable and creating a severe highway safety hazard. This vehicle was previously serviced under NHTSA Campaign 21V264000 (Subaru Recall WRE-21), which was intended to permanently remedy an ECM software defect that over-energizes and melts the ignition coils. Subaru of America (Case # 260630-2101598) is denying coverage, claiming that because the recall was executed 90,000 miles/5 years ago, and because the current software Calibration ID (CID) matches their post-recall database, the thermal melting is standard "wear and tear." I am filing this complaint because a safety recall remedy must be permanent and effective. The physical evidence, a melted plastic coil housing with a hole blown through it, is an engineering impossibility under normal wear and tear and proves that the original software patch…”

“Dangerous stall in traffic due to ignition coil failure. Ignition coils and spark plugs were replaced during the WRE21 recall campaign only 13k miles ago back in 2021. Stopped at red light awaiting to turn left when the vehicle started shaking violently. No check engine light came on though. When the light turned green, the vehicle was barely able to move forward then it completely stalled before pulling over to the curb. Since the tail of the car was sticking out into traffic a bit, it was a downright dangerous situation. Car had to be towed to dealership and took them 5 days to diagnose and fix the problem. Ignition coil and spark plug replacements costed 1500. Don't think the recall fixed the root problem and this could potentially happen again.”