2024 Toyota BZ4XRecalls, problems, MPG & safety

“The vehicle experienced a sudden, catastrophic brake-by-wire system failure while operating in one-pedal driving (Regeneration Boost mode). While decelerating at a low speed behind an 18-wheeler semi-truck, the vehicle failed to continue slowing down. I immediately depressed the physical brake pedal, but the vehicle completely ignored the foot pressure. The pedal and braking system became completely unresponsive, and the vehicle kept rolling forward uncommanded. Despite keeping the brake pedal fully depressed, the vehicle did not decelerate, resulting in a front-end low-speed collision with the metal rear bumper of the semi-truck. Because the collision occurred at a very low speed, the operator of the commercial truck was unaware of the impact and safely continued driving forward without stopping. The vehicle's brakes entirely refused to re-engage until I frantically pumped the physical brake pedal and cycled/pressed vehicle control power switches. This action seemingly forced the electronic braking modules to reboot or re-establish hydraulic pressure, allowing the vehicle to finally come to a stop. The vehicle was subsequently removed from the active roadway.…”

“I was driving during heavy rain when I heard and felt a big thump. I wasn't sure what happened as I did not hit anything in the road. I was in my neighborhood driving at low speeds (<30mph). When I got home, I realized my fender liners and lower splash guard of my car were missing. I went back out to retrieve these pieces of my car, and it appeared the fender liners and the splash guard got torn off my car without impact with anything, as nothing was in the road near it. I was going to attempt to reconnect them but the plastic clips on the front bumper also ripped off, making this a very expensive repair requiring bumper replacement and sensor recalibration. This obviously could put others at risk of running over a large number of components that were left in the road. I read many other instances of other people with the same vehicle (as well as with the Solterra) having an issue where the felt fender liners can become saturated with water, sag, and get caught in the wheels, ripping them off. I was one of those unlucky people to lose both sides and the splash guard all at the same time. The dealership / body shop inspected the vehicle. No warnings at all - just…”

“The vehicle experienced repeated electrical and brake system malfunctions that pose serious safety concerns. On multiple occasions, the brake pedal became stiff and unresponsive while driving, and the parking brake system failed to engage properly. In addition, the ignition system often failed to start, even when the battery and all power indicators appeared normal. At times, the vehicle’s electrical system completely shut down without warning — causing loss of power functions, dashboard lights, and essential safety controls. These failures occur intermittently and unpredictably, making the vehicle unreliable and unsafe to operate. The issue has been reported to the dealer for inspection, but the problem continues to occur. It appears to be related to the vehicle’s electronic brake control and ignition system. This malfunction places the driver and others at potential risk, especially if the brake system or electrical components fail while the vehicle is in motion.”