2004 Toyota Sienna equipment problems

“TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. WHILE PARKED, THE CONTACT NOTICED A FRACTURE ON THE DRIVER'S SIDE OF THE DASHBOARD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A COMPLAINT WAS FILED. ADDITIONALLY, THE CONTACT HEARD A GRINDING NOISE COMING FROM THE AIR CONDITIONING UNIT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE AIR CONDITIONING COMPRESSOR WOULD HAVE TO BE REPLACED. ALSO, THE CONTACT STATED THERE WAS RUST ON THE REAR DRIVER AND PASSENGER SIDE SLIDING DOORS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE HINGE WAS REPLACED. THE SLIDING DOOR FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. ...UPDATED 10/17/12 *BF UPDATED 10/23/2012 *JS”

“DESCRIPTION: FRONT DOOR CHECK POPPING NOISE CAUSE: SPOT WELD IN DOOR CHECK FAILED CONTROLS DOOR WHEN OPENING AND CLOSING SAFELY. TOYOTA HAS TSB NV003-07, BUT HAS LIMITED WARRANTY. EXPIRED FOR ME. *TR”

“I HAVE A 2004 TOYOTA SIENNA VAN AND I AM VERY DISTURBED BY THE POWER DOOR PROBLEMS I HAVE HAD SINCE DAY 1 OF OWNING THIS VEHICLE. THE SLIDING DOORS FREEZE UP ALL THE TIME IN THE WINTER. AFTER DRIVING FOR APPROX. 30-45 MINUTES THE DOOR WILL UNFREEZE & COME OPEN! I HAVE TWO CHILDREN!!! THIS IS A SAFETY HAZARD AS WELL AS BEING A NUISANCE. ALSO THE POWER DOOR CABLE SNAPPED IN TWO. I CALLED HICKORY TOYOTA & SPOKE WITH MAINTENANCE CUSTOMER SERVICE, WHICH INFORMED ME THAT THIS JUST DOES NOT HAPPEN. I SAID WELL, IN MY CASE IT DID! I WANT THIS FIXED BEFORE ONE OF MY CHILDREN GET HURT & THIS BECOMES A LAW SUIT! THIS IS MY 2ND SIENNA VAN & HAD THE SAME PROBLEM WITH IT. I'VE HAD THREE CAMRYS AND THEY WERE ALMOST PERFECT. WHAT IS UP SIENNA??!! MAYBE I NEED TO CONVERT TO HONDA AFTER ALL. :( *LN”

“MY 2004 TOYOTA SIENNA XLE LIMITED POWER SLIDING DOOR CABLE SNAPPED AND DOOR WOULDN'T CLOSE, THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA SHOULD TAKE RESPONSIBILITY OF FIXING THIS ON GOING ISSUE WITH THESE SIENNA VANS. THERE COUNTLESS NUMBER OF PEOPLE HAVE THE SAME ISSUE. DEAL COST TO FIX THIS IS OVER $2000. THIS IS TOTALLY UNFAIR FOR CONSUMERS TO PAY SUCH HIGH COST REPAIR FOR WHAT TOYOTA IS RESPONSIBLE FOR IN FIRST PLACE. *TR”

“THE SLIDING DOORS ON OUR TOYOTA SIENNA ARE DEFECTIVE. THEY STICK SHUT FREEZE IF THE TEMPERATURE GETS LOW ENOUGH OR THERE IS ENOUGH MOISTURE. IT'S HARD TO PREDICT THE CIRCUMSTANCE BUT THE FACT IS, OUR KIDS CANNOT GET IN OR OUT OF THE VAN AND WE HAVE HAD TO DRIVE IT ANYWAY, THREE DIFFERENT BEEPERS GOING OFF ALL THE WAY. I HAVE READ THAT THIS IS A COMMON PROBLEM FOR THE SIENNA AND YET TOYOTA CONTINUES TO DO NOTHING ABOUT IT, DENYING IT, IN FACT. IF WE WERE IN AN ACCIDENT, AND HAD TO ESCAPE QUICKLY, ONLY THE DRIVER AND PASSENGER COULD ESCAPE. WHEN SIDE DOORS ARE FROZEN SHUT, KIDS HAVE TO EXIT THROUGH THE BACK DOOR WHICH IS ALSO DANGEROUS. I KNOW MY 2004 IS PAST THE WARRANTY, BUT IF THIS IS A COMMON A PROBLEM AS I HAVE READ, SHOULDN'T THERE BE A RECALL? *TR”

“WHILE I WAS TRYING TO OPEN MY 2004 TOYOTA SIENNA PASSENGER POWERED SLIDING DOOR THE CORD RIPPED. IT IS TOO COSTLY FOR US TO REPAIR THIS ITEM AND I CAN NOT USE THE DOOR WITH CHILDREN AS IT IS TO HARD TO OPEN FOR A MINOR.”