2016 Volkswagen Golf SportwagenRecalls, problems, MPG & safety

“SRS/airbag warning light illuminated. A diagnostic scan (VCDS) confirmed stored fault codes for both front airbag crash sensors: driver's side 'short to ground' and passenger's side 'open or short to plus.' Upon further inspection, water was found pooled at the airbag control module connector, located under the center dash. The AC condensate drain line is routed directly above this module, and appears to be the source of the water intrusion — water drained from the connector itself when disconnected, and dampness was present at both the upper and lower AC drain hose connections near the module. After drying and reconnecting all components, an attempt was made to clear the fault codes via VCDS. The airbag module returned a 'not acknowledged' response to the clear command, indicating the fault condition and/or internal component damage may still be present. This vehicle's VIN was checked against active airbag recalls for this model year and found not to be included. However, given the safety-critical nature of the SRS system and the apparent design proximity of the AC drain to the airbag module connector, this may represent a broader risk for this chassis.…”

“Junction between thermostat and water pump failed leading to total loss of coolant. At the time I was driving north on I-75 in heavy morning traffic at 65 MPH. I was able to steer the vehicle off the road without hitting anyone or coming to a complete stop. Had the vehicle towed to Jim Ellis VW of Kennesaw where they diagnosed the problem and replaced the water pump. The car had 18,762 miles on it at the time. Mechanic stated that the problem was oil from cam covers leaking onto water pump and was frequently seen. Vehicle had low coolant warning lights twice and I added several ounces of distilled water each time. Car had an engine warning light and was being taken to dealer for service that day. When the incident happened, there was an audible alarm for loss of coolant and a flashing yellow light on the dashboard. The car had been serviced and inspected at the dealership annually, there had been no reports of leaking oil from cam covers. There was no indication the water pump would catastrophically fail. The waterpump should not fail with this few miles on it. .”

“Despite settling a class action lawsuit re: moonroof leakage, VW refuses to cover the same repair for my VW Golf Sportwagen. I have the same issue but could not participate in the class action suit due to mileage. I routinely have to bail 1/2 - 1 gallon of water out the spare tire area if its been raining. Water now also collects in the footwell behind the driver's seat/in front of my child's seat. The bolts affixing the seatbelts to the floor are rusted and there is mold under the carpet. The car now has electrical issues, including the alarm no longer sounding when I am reversing and someone is approaching in my blind spot. In addition, when the weather has been wet, the back up camera does not work and, mid trip, the car alarms sound, indicating the car must be serviced and the brakes and airbags are not working. These problems disappear after a few days of dry weather.”