2009 Volkswagen Passat problems

“The check engine light and oil pressure light appeared on my dash screen as I was driving home from work. I pulled over to the nearest repair shop to have the vehicle diagnosed. Upon arriving, the mechanic noticed my oil was low and filled the car with oil. Once that was completed, the car would not start. I noticed it made unusual noises after several more failed attempts. I had the vehicle towed to an authorized dealership to further troubleshoot and they were able to confirm that the engine jumped time due to a failed timing chain tensioner, which requires a new engine since mine is an interference engine. Due to the timing chain tensioner failing, there was catastrophic damage done to the engine leaving the vehicle inoperable.”

“On [XXX], a MIDAS shop found an alleged crack in the front part of the gas tank on the upper part of the tank by the floor board. The manager also stated that it could be a plastic seal from the fuel pump on the top part of the tank. The tank is located next to the exhaust system. My 2009 VW CC 4-Motion only has 122,xxx miles on it. I could see a wet spot and presumed I smelled gas but was not sure. He gave me a printout of what the cost would be to repair the system. I told him I would be filing a report with NHTSA. I then called Lunde's VW, W. Bell Rd., Peoria, AZ. I talked to a Tyler Rodriquez and he said there were no recalls and VW could not warrant the problem. I told him I would be filing a report with NHTSA and he did not respond to me. Both places were quite fast to elicit repairs from their business. Only MIDAS pointed out the exhaust pipes being near the gas tank. Approximately six years ago I had been to another VW dealership in Phoenix about my gas gauge needle not working properly and I was sold a gas cap to fix the problem. The problem has been a recurring one and my gas mileage fluctuates. This situation reminds me of the mid-1970s problem with…”

“The power steering system failed. At first I thought the steering wheel was locked. I started the car and could not turn the wheel. The power steering light illuminated in red and there was a loud beeping sound when the car is turned on. It was not until the car was towed that I realized that the wheel was not locked. The tow truck driver was able to turn the wheel to steer the vehicle on to the truck bed. I had someone plug in a diagnostic machine. I do not recall the exact code but he said the power steering system was not getting a signal. He replaced the steering angle sensor but that did not fix the issue. I had passenger at the time and was concerned for my safety. Luckily, the system failed while the car was parked, but we were left stranded. I have come across the following information on the Kelley Blue Book website: Steering: gear box (other than rack and pinion) NHTSA CAMPAIGN ID: 08V577000 Report Date: Oct 31 2008 Vehicles Affected: 130 Consequence: DRIVER ATTEMPTS TO OVERCOME THE SYSTEM DURING MALFUNCTION WILL CAUSE (1) VIBRATIONS IN THE STEERING WHEEL; (2) THE STEERING SYSTEM MOTOR TO TURN OFF; (3) THE RED STEERING SYSTEM MALFUNCTION INDICATOR…”

“THE CAR HAS STALLED MULTIPLE TIMES WHILE DRIVING. LIGHTS POP ON AND THE FUEL PUMP IS THE ERROR CODE, ALONG WITH MISFIRES. I HAVE HAD AT LEAST A DOZEN OR MORE CLOSE CALLS WITH THE STALL OUT AND FAILURE TO START UP, AND AT LEAST 2-3 TIMES I HAVE ALMOST BEEN SERIOUSLY INJURED OR KILLED DUE TO THE STALL OUT. IT STALLS WHEN ITS IN MOTION OR EVEN WHEN IT IS PARKED AND IS STARTING UP.”

“RECALL UPDATE: CURRENTLY, INTAKE MANIFOLD NEEDS TO BE REPAIRED-ENGINE LIGHT ON-COST $1400.00. TOOK CAR TO DEALERSHIP FOR FUEL PUMP WAS TOLD IT WAS REPLACED BUT WOULD NOT GIVE EVIDENCE THAT IT WAS. SIDE FRONTAL AIR BAG NEVER REPLACED-WAS TOLD BY DEALERSHIP DID NOT NEED IT.”

“MY VW PASSAT 2009 SUSTAINED ENGINE FAILURE DUE TO FAILURE TIMING CHAIN/TIMING CHAIN TENSIONER AND NOW NEEDS VERY EXPENSIVE ENGINE REPAIR OR REPLACEMENT OF ENGINE. CAR DROVE OKAY FOR 15 MINUTES IN THE MORNING THEN IT WAS THEN PARKED FOR ABOUT 2 HOURS. WHEN TRYING TO RE-START THE CAR, THE CAR WOULD NOT START. MECHANIC NOTED ABSENT COMPRESSION IN 2 CYLINDERS AND DIAGNOSED IT TO BE DUE TO TIMING CHAIN SLIPPING. THIS HAPPENED AT 80,000MILES AND LESS THAN 10 YEARS (9 YEARS 9 MONTHS) OF PURCHASE OF THE VEHICLE. VW'S EXTENDED WARRANTY COVERS REPAIR/REPLACEMENT OF TIMING CHAIN BUT DOES NOT COVER REPAIR OF ENGINE DAMAGE RESULTED DUE TO TIMING CHAIN FAILURE. THE CAR WAS SERVICED AT VW DEALER REGULARLY AND THERE WAS NO WARNING OR INDICATION OF IMPENDING FAILURE OF THE TIMING CHAIN. OTHER OWNERS OF VW VEHICLES HAVE ALSO COMPLAINED OF HAVING IDENTICAL PROBLEMS ON ONLINE COMMUNITY WITH SOME PEOPLE COMPLAINING OF ENGINE STALLING WHILE DRIVING. THIS APPEARS TO BE A DEFECTIVE DESIGN RATHER THAN WEAR AND TEAR DUE AGEING AND I FEEL THAT VW SHOULD RECALL THE AFFECTED VEHICLES TO REPAIR THE PROBLEMS.”