NHTSA lists 5 safety recalls and 33 owner complaints for the 2004 Cadillac XLR. Most complaints involve structure (10) and fuel system, gasoline (5). The EPA rates it 18 mpg combined.
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
ON CERTAIN PASSENGER VEHICLES, THE DAYLIGHT RUNNING LIGHTS (DRL), TURN SIGNAL, AND PARKING LAMPS USE THE SAME BULB. THE BULB MAY BECOME DAMAGED FROM VIBRATION WITHIN A LOOSE FITTING SOCKET OR AIR ENTERING THE BULB DUE TO AN INADEQUATE SEAL. BOTH OF THESE CONDITIONS WILL CAUSE THE BULB TO BURN OUT PREMATURELY.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The contact owns a 2004 Cadillac XLR. The contact stated that while driving approximately 70 MPH, there was an abnormal sound like a shotgun being fired overhead. The contact pulled over and observed that the retractable fiberglass roof panel had detached from the frame of the vehicle. The contact stated that the headliner, cables, and pulleys used to retract the roof were exposed. The contact was unable to recover the panel. The contact called the dealer and the manufacturer and was informed that there were no recalls on the VIN for the failure. The contact was informed that the roof panel could be replaced out-of-pocket. The vehicle was not repaired. The failure mileage was approximately 88,000.”
“The contact owns a 2004 Cadillac XLR. The contact stated that fuel had begun to leak from the fuel pump without warning. The contact took the vehicle to an independent mechanic who diagnosed the failure and informed him that while the motor was running, the fuel would leak from the rear driver's side wheel; the leak would stop once the engine was shut off. The mechanic later discovered NHTSA Campaign Number: 11E009000(Fuel System, Gasoline) which he linked to the failure. The dealer was notified and an appointment was made for a diagnostic. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was 24,089.”
“TL* THE CONTACT OWNS A 2004 CADILLAC XLR. WHILE THE VEHICLE WAS BEING PULLED INTO THE GARAGE, THE CONTACT NOTICED THAT THE HEADLIGHTS MELTED AND MADE IT IMPOSSIBLE FOR THE CONTACT TO SEE CLEARLY. THE CONTACT CALLED SEVERAL DEALERS, INCLUDING WALLACE CADILLAC (772-286-3555, LOCATED AT 3555 SE FEDERAL HWY, STUART, FL 34997). THE CONTACT WAS INFORMED THAT THEY NO LONGER MADE THOSE TYPE OF HEADLIGHTS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH SEVERAL WEBSITES TO SEARCH FOR USED HEADLIGHTS. THE CONTACT FOUND A COMPANY IN CHICAGO THAT HAD THE HEADLIGHTS, BUT THE COST WAS TOO EXPENSIVE. THE CONTACT MADE AN OFFER THAT WAS NOT ACCEPTABLE TO THE SELLER. THE CONTACT CALLED SEVERAL OTHER COMPANIES, INCLUDING EBAY, BUT WAS UNSUCCESSFUL. THE CONTACT CALLED THE FEDERAL TRADE COMMISSION AND THE STATE ATTORNEY GENERAL AND BOTH REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| XLR Auto 5-spd, 8 cyl, 4.6 L · Rear-Wheel Drive | 15 | 23 | 18 | $4,300 | 494 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
5 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 33 complaints with NHTSA. The most-cited components are structure (10), fuel system, gasoline (5), exterior lighting (4). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2004 Cadillac XLR at 18 mpg combined, depending on engine and drivetrain (1 version rated).