NHTSA lists 1 safety recall and 163 owner complaints for the 2008 Chevrolet Aveo. Most complaints involve air bags (70) and electrical system (44). The EPA rates it 26–27 mpg combined.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The contact's son owns a 2008 Chevrolet Aveo. The contact stated that while her son was driving at an undisclosed speed, the passenger's side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.”
“There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.”
“The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated no warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V261000 (EXTERIOR LIGHTING) however the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was informed of failure and told the contact that they were able to assist but would not without the contact having computer access. The failure mileage was approximately 110,000.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Aveo Man 5-spd, 4 cyl, 1.6 L · Front-Wheel Drive | 24 | 34 | 27 | $2,300 | 329 |
| Aveo 5 Man 5-spd, 4 cyl, 1.6 L · Front-Wheel Drive | 24 | 34 | 27 | $2,300 | 329 |
| Aveo Auto 4-spd, 4 cyl, 1.6 L · Front-Wheel Drive | 23 | 32 | 26 | $2,400 | 342 |
| Aveo 5 Auto 4-spd, 4 cyl, 1.6 L · Front-Wheel Drive | 23 | 32 | 26 | $2,400 | 342 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
1 safety recall as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 163 complaints with NHTSA. The most-cited components are air bags (70), electrical system (44), exterior lighting (30). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2008 Chevrolet Aveo at 26–27 mpg combined, depending on engine and drivetrain (4 versions rated).