NHTSA lists 11 safety recalls and 363 owner complaints for the 1998 Chevrolet Cavalier. Most complaints involve electrical system (66) and steering (57). The EPA rates it 23–25 mpg combined.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“THE GAS GAUGE IS GOING HAYWIRE. IT PEGS TO THE "F", AND THEN IMMEDIATELY PEGS TO THE "E", EVEN THOUGH THE TANK IS HALF FULL. THE GAUGE THEN JUMPS AROUND THE MIDDLE FORM ONE SIDE TO THE OTHER SIDE. IT IS IMPOSSIBLE TO TELL HOW MUCH IS IN THE TANK. THIS HAPPENS WHILE DRIVING AND ALSO WHILE SITTING AT LIGHTS OR STOP SIGNS.”
“TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING IN REVERSE APPROXIMATELY 5 MPH, THE CONTACT ATTEMPTED SEVERAL TIMES TO TURN THE STEERING WHEEL BUT THE STEERING WHEEL WOULD NOT RESPOND. THE FAILURE WAS A CONTINUOUS OCCURRENCE IN ANY SELECTED GEAR. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 02V286000 (STEERING: RACK AND PINION) BUT WAS ADVISED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED FOR THE FAILURE. THE VEHICLE WAS NO LONGER BEING DRIVEN. THE FAILURE MILEAGE WAS 139,000. UPDATED 5/24/11 *CN UPDATED 1/18/2012 *LN *TR”
“I HAVE ALWAYS HAD TROUBLE WITH THE ABS SYSTEM AND SO DID MY FATHER-IN-LAW WHO DROVE CAR BEFORE ME. ABS WAS ALWAYS VERY SENSITIVE TO ACTIVATING AND WHEN ACTIVATED VEHICLE VERY DIFFICULT TO STOP. I HAVE BE DRIVING 40 YEARS AND NEVER OWNED A MORE DIFFICULT VEHICLE TO STOP. HAD BRAKES SERVICED LESS THAN 10,000 MILES AGO AT DEALER, HAVE BRAND NEW MICHELINS. DOES NOT MATTER, I SEE A LOT OF COMPLAINTS ON INTERNET ABOUT THIS CAVALIER ABS SYSTEM AND IT IS DANGEROUS. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Cavalier Man 5-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 21 | 31 | 25 | $2,500 | 355 |
| Cavalier Man 5-spd, 4 cyl, 2.4 L · Front-Wheel Drive | 20 | 30 | 24 | $2,600 | 370 |
| Cavalier Auto 3-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 20 | 27 | 23 | $2,700 | 386 |
| Cavalier Auto 4-spd, 4 cyl, 2.2 L · Front-Wheel Drive | 20 | 28 | 23 | $2,700 | 386 |
| Cavalier Auto 4-spd, 4 cyl, 2.4 L · Front-Wheel Drive | 20 | 30 | 23 | $2,700 | 386 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
11 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 363 complaints with NHTSA. The most-cited components are electrical system (66), steering (57), service brakes, hydraulic (56). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1998 Chevrolet Cavalier at 23–25 mpg combined, depending on engine and drivetrain (5 versions rated).