2018 Chevrolet Colorado problems

“While driving at normal and safe highway speeds, without warning (no audible or visual warning from the vehicle information display) my vehicle experienced engine lockout, loss of all non-electric power, and no control over vehicle speed. A few seconds after loss, the information display did show a "check engine light" and that the engine was in "lockout." We (my spouse, young child, and self) were surrounded by multiple commercial semi-trucks and passenger vehicles and had to weave and serve to avoid collisions at highway speeds and get to the shoulder of the highway in a few seconds. The root cause as diagnosed by a Chevrolet Dealership Service Department was failure of the magnetic strip that is press fit to the reluctor (tone) wheel. A 1/2in piece of the magnetic strip was missing and over 10 cracks within the strip itself observed. This magnetic strip is used by the Engine Control Module to measure engine RPMs. The strip's failure caused the EMC to shutdown the engine without warning which is a significant hazard for controlled vehicle movement at highway speeds. My vehicle's engine (LWN) is one of the few GM designs that have the press fit magnetic strip…”

“The contact owns a 2018 Chevrolet Colorado. The contact stated that while the vehicle was parked, the key was difficult to remove from the ignition. The dealer was contacted and informed that the shift interlock switch failed to recognize that the transmission was shifted to park(P). The vehicle was not repaired. The manufacturer was contacted, but offered no assistance because the vehicle was not under warranty. The failure mileage was approximately 60,000.”

“Crankshaft Position Tone Wheel delaminated, mechanic changed it out and not sure what they did with it. Stalled vehicle on uphill passing lane during rush hour traffic, cars where inches from me as they passed at 65-70 mph, I called 911 and had a state trooper come and direct traffic. Joe's Garage inspected my vehicle and did the repair. It was not inspected by anyone besides Joe's Garage to my knowledge. No warning, dashlights came on after engine stalled.”

“Power steering failure, without incident. It started one morning, after turning off truck the previous day. Warning lights displayed as soon as truck was started. Very difficult to turn steering wheel. Too dangerous to drive. Dealer indicated the steering rack should be replaced.”

“My 2018 Chevrolet Colorado diesel has had repeated diesel emissions/DPF-related failures that cause the vehicle to enter reduced-power or limp mode. This is a safety issue because the truck suddenly loses power and cannot accelerate normally. The most serious incident occurred while driving over Santiam Pass in Oregon. The vehicle went into reduced-power/limp mode on a mountain highway, leaving me unable to maintain normal speed or accelerate safely. I lost power needed to pass traffic and had limited ability to respond to road conditions. The problem has happened several times. It has also occurred while I was towing my boat, which left me unable to continue the trip safely and created a hazardous situation because the truck could not maintain normal towing power. The issue appears related to the diesel particulate filter/emissions system and repeated DPF/regen or exhaust aftertreatment problems. I am concerned that a design, calibration, or emissions-system defect is causing sudden power reduction during normal driving and towing. This creates an unreasonable safety risk, especially on mountain passes, two-lane highways, and while towing. I am requesting that…”

“All the sensors seem to not be functioning correctly. Doesn't tell me the right measurements for the wheels, gas, over heating. Right front passenger door locks/unlocks when it wants. It chokes up when trying to accelerate. Theres a rattling noise that comes from under the car. First time I took it to the dealership, they stated it was a bolt that had come loose on the exhaust pipe. They placed a new one which lasted a year and a half and now its back to making the noise. I took it again to the dealership, this time they claimed they couldn't find anything. My airbag sensor keeps coming on constantly. My fuel sensor claims 116 miles one moments and 5 or 6 minutes later, it says I have 50 miles. My car was over heating and low on Anti-freeze, the car never notified it was over heating.”