NHTSA lists 7 safety recalls and 24 owner complaints for the 2016 Chevrolet SS. Most complaints involve steering (12) and seat belts (6). The EPA rates it 16–17 mpg combined.
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS and Caprice Police Pursuit Vehicles (PPV) that were previously repaired under NHTSA recall number 16V-518. The repair may not have been performed properly. The driver's seat belt tensioner cable may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Caprice Police Pursuit vehicles (PPV) and SS vehicles. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
General Motors LLC (GM) is recalling certain 2014-2016 Chevrolet SS vehicles that previously received an inspect-only remedy under recall 17V-382. Corrosion of the connector between the electric power steering module and the torque sensor connector may cause a loss of electric power steering assist.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“A few days ago I was heading home from work and sport mode automatically turned on and the “service power steering” warning came on. Then the steering wheel stiffened up 2 times for a few seconds while I was driving. I looked into it and there was a recall before I purchased the vehicle and it was repaired also. But it is the same problem. I contacted the dealer ship but they said there’s no warranty on recalls. I did purchase the car from a used car dealership and still paying it. Car still isn’t running and seems like an expensive repair.”
“FILED SECOND TIME. RECALL REPAIR IS DEFECTIVE! RECALL REPAIR HAS LEFT SEAT BELT TENSIONER CABLE EXPOSED AND FLOPPING! METAL BITS AND PIECES ARE NOW ON CARPET AND AREA AROUND SEAT BELT FOUNDATION AND LOWER REPLACED COVER AREA. THE REPLACED RUBBER COVER (92507580) IS RIPPED AND RIPPING MORE AT LOWER CONNECTION OF EXPOSED TENSIONER CABLE. DONT UNDERSTAND RECALL? TAKE CAR IN TWICE (11/7/2016) (12/1/2016) WRONG PARTS TWICE, THIRD TIME 6 MONTHS LATER (5/1/2017) CAR SEAT BELT DAMAGED FROM RECALL REPAIR????”
“THE BLIND SPOT SENSOR STARTED NOT TO WORK SPORADICALLY STARTED NOT TO WORK AT 36,500 MILES. NOW THEY DON'T WORK AT ALL AND AT LEAST I AM NOTIFIED OF THIS TWO TO THREE TIMES EVERY USE OF THE VEHICLE. TALKED AND RESEARCHED THIS WHICH IS A COMMON ISSUE WITH GM CARS AND TRUCKS OF MY CARS VINTAGE. GM KNEW OF THE DESIGN ISSUE BEFORE THEY BUILT THE CAR BUT DIDN'T REPLACE IT.”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| SS Man 6-spd, 8 cyl, 6.2 L · Rear-Wheel Drive | 14 | 22 | 17 | $3,650 | 520 |
| SS Auto (S6), 8 cyl, 6.2 L · Rear-Wheel Drive | 14 | 20 | 16 | $4,850 | 556 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
7 safety recalls as of Nov 8, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 24 complaints with NHTSA. The most-cited components are steering (12), seat belts (6), electrical system (4). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2016 Chevrolet SS at 16–17 mpg combined, depending on engine and drivetrain (2 versions rated).