NHTSA lists 9 safety recalls and 1,404 owner complaints for the 1996 Ford Windstar. Most complaints involve engine and engine cooling (472) and power train (319). The EPA rates it 18 mpg combined.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. DURING ASSEMBLY, SOME BRAKE LINES WERE INSTALLED IN A TWISTED POSITION, CAUSING CONTACT WITH THE DASH PANEL INSULATOR ABOVE THE CATALYTIC CONVERTER. THIS CONTACT COULD ABRADE THE BRAKE LINE CORROSION PROTECTION, CONSEQUENTLY, SALT OR WATER ABSORBED IN THE DASH PANEL INSULATOR WOULD PROMOTE CORROSION. THIS CORROSION COULD ULTIMATELY LEAD TO A LEAK IN THE BRAKE LINE.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1998 FORD WINDSTAR MINIVANS. THE FRONT COIL SPRINGS COULD POTENTIALLY FRACTURE DUE TO CORROSION. NOTE: THE 1997-1998 WINDSTAR MINI VANS ARE ALSO COVERED BY NHTSA SAFETY RECALL 01V-199/FORD RECALL 01S19. THE MINI VANS COVERED BY THE SAFETY RECALL WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“I PURCHASED A 1996 FORD WINDSTAR VAN 3.0 L IN JUNE 2010. I HAVE HAD NUMEROUS ISSUES WITH THIS VEHICLE FROM DAY 1 TO CURRENT MOST DANGEROUS IS THE BLOWING SPARK PLUG WHICH HAS BLOWN OUT 2 TIMES FORCING ME TO DRIVE IT TO A PLACE WHERE IT COULD BE PARKED FOR REPAIR FIRST TIME BLOW OUT WAS 7 DAYS AFTER PURCHASE REPAIRED BY A MECHANIC NOW 2000 MILES LATER AGAIN BLEW OUT FORD SHOULD BE ASHAMED OF THEMSELVES FOR IGNORING SUCH A HUGE HAZARD THIS COULD SERIOUSLY IGNITE FUEL FUMES AND CAUSE A MAJOR FIRE, EXPLOSION WHILE SOME ONE IS DRIVING WITH THERE CHILDREN TO FIND A REPAIR SHOP UNAWARE OF THE DANGER AND DAMAGE THIS COULD CAUSE, SECOND ISSUE IS A FAILING SHIFTING MODULE OR TRANNY AND THIS HAS HAPPENED ALOT DRIVING AND ALL OF A SUDDEN THE VANS TRANSMISSION SHIFTS TO A 1ST OR 2ND GEAR CAUSING EXTREME CHANGE IN SPEED AND IN HEAVY TRAFFIC WE HAVE ALMOST BEEN REARENDED SEVERAL TIMES DUE TO THIS ISSUE, VESSIL MUST BE PULLED OVER AND TRANS RESET BY SHIFTING TO PARK AND SOMETIMES SHUTTING OFF THE VEHICLE AND STARTING IT AGAIN.FORD DEALER GAVE US A 3000. ESTIMATE TO REPLACE TRANSMISSION AND TOLD US WE WOULD CONTINUE TO REPLACE TRANS APROX EVERY 70,000 MILES THIS IS A CHUMP WAY…”
“TL* THE CONTACT OWNS A 1996 FORD WINDSTAR. WHILE AT A STOP LIGHT, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE ABOVE 20 MPH. THE SERVICE BRAKE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.”
“HAD CHANGED BRAKE PADS A WEEK EARLIER. DRIVING 55MPH AND THE CAR CRASHED DOWN ON IT'S AXLE AS THE TIRE AND WHEEL PASSED BY US GOING DOWN HIGHWAY, IN 37 NORTH. STUDS HAD ALL BROKEN OFF. THE DISC BRAKE IS RUINED FROM SKIDDING ON IT. TRAFFIC WAS MODERATELY HEAVY. WE SKIDDED TO A STOP ON A BRIDGE AND FEEL LUCKY NOT TO HAVE CRASHED INTO ANYONE. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Windstar FWD Van Auto 4-spd, 6 cyl, 3.0 L · Front-Wheel Drive | 15 | 23 | 18 | $3,450 | 494 |
| Windstar FWD Van Auto 4-spd, 6 cyl, 3.8 L · Front-Wheel Drive | 15 | 22 | 18 | $3,450 | 494 |
| Windstar FWD Wagon Auto 4-spd, 6 cyl, 3.0 L · Front-Wheel Drive | 15 | 23 | 18 | $3,450 | 494 |
| Windstar FWD Wagon Auto 4-spd, 6 cyl, 3.8 L · Front-Wheel Drive | 15 | 22 | 18 | $3,450 | 494 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
9 safety recalls as of Nov 9, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 1,404 complaints with NHTSA. The most-cited components are engine and engine cooling (472), power train (319), service brakes, hydraulic (214). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1996 Ford Windstar at 18 mpg combined, depending on engine and drivetrain (4 versions rated).