NHTSA lists 4 safety recalls and 37 owner complaints for the 2022 Hyundai Santa Fe Hybrid. Most complaints involve power train (13) and engine (13). The EPA rates it 32–34 mpg combined, and NHTSA gives it 5 stars overall.
Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The vehicle has suffered a catastrophic structural manufacturing defect involving a transmission case half seal failure. The transmission is actively seeping/leaking fluid directly from the factory-mated case assembly line seal. This presents a severe, progressive safety hazard. Transmission fluid leaking from the case half migrates along the underbody of the vehicle and directly coats hot exhaust and powertrain components during highway operation. This creates an immediate risk of under-hood smoke, thermal degradation, component stalling, or a potential vehicle fire at high speeds. Certified diagnostic inspection confirms this is a factory assembly defect (defective RTV sealant application or improper factory bolt torque) and not mechanical wear-and-tear or driver neglect. The vehicle currently has 88,000 miles, but the structural failure was first physically documented by a licensed facility at 59,870 miles. The manufacturer (Hyundai Motor America) has currently refused to honor the powertrain failure, forcing the vehicle to remain on the road with an active powertrain fluid leak risk.”
“While accelerating at a light, the accelerator became unresponsive, only propelling the vehicle a couple miles per hour. I was not able to pull over, as I was in the left lane of a very busy road. After about 15 seconds of lack of acceleration, the accelerator responded enough for me to pull over. I’m glad this incident did not occur on a highway, during a turn, or other hazardous situations. Dash displayed, “Check hybrid system. Pull over safely”. There was no indication or issue with the vehicle prior to this. I haven’t had any issues since I bought it several months ago. I’ve read reports of this same issue happening with this same model. I have a scheduled date for inspection.”
“vehicle will not change out of EV electric mode and return to gas power causing hybrid battery drains to zero, vehicle loses acceleration, you can push the gas pedal to the floor and you have no acceleration, very UNSAFE when you are in traffic, no power to maneuver or avoid other vehicles quickly if needed, potential for accidents, hybrid system warning lights and alarms go on, have to try and pull over safely, battery will not recharge or takes a very long time to do so, only recourse is to shut vehicle off and restart which seems to reset vehicle, which in turn does not leave any warning lights other than codes on to show dealer, very dangerous to lose all acceleration capacity while in traffic, this has happened multiple times with the latest being today 3/23/25, vehicle is available for you to inspect, have had other powertrain codes issues as well, dealer has replaced fuel pump and erg valve but it does not resolve this hybrid issue, this battery drain issue has occurred multiple times but no resolution, help!”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Santa Fe Hybrid Blue Auto (AM-S6), 4 cyl, 1.6 L, Turbo · All-Wheel Drive | 36 | 31 | 34 | $1,900 | 264 |
| Santa Fe Hybrid Auto (AM-S6), 4 cyl, 1.6 L, Turbo · All-Wheel Drive | 33 | 30 | 32 | $2,000 | 283 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Oct 30, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 37 complaints with NHTSA. The most-cited components are power train (13), engine (13), electrical system (8). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2022 Hyundai Santa Fe Hybrid at 32–34 mpg combined, depending on engine and drivetrain (2 versions rated).
NHTSA's New Car Assessment Program gives the 2022 Hyundai Santa Fe Hybrid 5 out of 5 stars overall.