NHTSA lists 3 safety recalls and 42 owner complaints for the 2005 Mazda MPV. Most complaints involve air bags (10) and engine (6). The EPA rates it 19 mpg combined.
Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. On July 9, 2019 this recall was expanded to include certain 2005-2009 RX-8 vehicles that were previously recalled under 17V-011 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“Takata recall. The contact owns a 2005 Mazda MPV. The contact received notification of NHTSA Campaign Number: 18V404000 (Air Bags) however, the nearest dealer location was nearly 5 hours away. The manufacturer was notified of the issue and attempted to send a mechanic from the dealer to the residence for the recall repair however, the dealer declined. The contact was then referred to a Subaru dealer for assistance; however, the manufacturer failed to send the part to the dealer. The contact had gone back and forth with the manufacturer and other dealers but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.”
“ENGINE STALLS OR SHUT DOWN COMPLETELY WHEN AUTO MOVES FROM HIGH SPEED TO LOW SPEED. MAZDA 6 W/ 3.0 LITER ENGINE, WHICH IS THE SAME ENGINE AS THIS UNIT, HAS A SIMILAR ISSUE - SEE HERE: HTTP://WWW.6CREW.COM/FILES/TSB/01-016-06-2135.PDF THIS IS HAPPENING PERSISTENTLY FOR THE LAST 2 YEARS.”
“MY MAZDA 2005 MPV VAN ENGINE SHUTS DOWN COMPLETELY WHEN SLOWING DOWN, SLOWING AROUND CORNERS AND SITTING AT RED LIGHTS. THERE DOES NOT SEEM TO ANY SPUDDERING OR ANYTHING ENGINE RUNS GREAT. LOSS OF STEERING IS THE BIGGEST ISSUE WHEN ENGINE CUTS OFF. I HAVE SEEN A BUNCH OF OTHER COMPLAINTS ABOUT THE SAME PROBLEM ON THE SAME MODEL VAN IM SURE THERE'S LOTS MORE. *TR”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| MPV Auto 5-spd, 6 cyl, 3.0 L · Front-Wheel Drive | 16 | 23 | 19 | $3,400 | 468 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
3 safety recalls as of Oct 28, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 42 complaints with NHTSA. The most-cited components are air bags (10), engine (6), engine and engine cooling (6). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2005 Mazda MPV at 19 mpg combined, depending on engine and drivetrain (1 version rated).