NHTSA lists 4 safety recalls and 196 owner complaints for the 2005 Chevrolet Uplander. Most complaints involve electrical system (57) and structure (45). The EPA rates it 17–18 mpg combined.
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“DRIVING THE VEHICLE ALONG THE INTERSTATE AT 65 MPH AT NIGHT, THE IGNITION SWITCH RUN POSITION ROTATED TO OFF AND THE ENGINE AND ALL HEADLIGHTS, DASH, ETC, SHUTDOWN ALONG WITH THE POWER STEERING AND POWER BRAKES. THE INCIDENT HAS JUST STARTED HAPPENING AND 340,000 MILES ON IT. ONLY WAY TO GET ROLLING IS TO PUT THE AUTO TRANS LEVER TO NEUTRAL AND TWIST THE IGNITION KEY TO CRANK POSITION AND LET KEY SETTLE TO RUN POSITION. THE IGNITION SWITCH ITSELF HAS A SPRING DETENT AND IT SETS IN A POCKET AT RUN. SO THIS SWITCH HAS A SPRING THAT OVER TIME WEAKENS AND ALLOWS THE WHOLE KEY CYLINDER ANS SWITCH TO DROP OUT OF RUN AND SHUT OFF THE ELECTRICAL. SOLUTION WAS TO PUT IN A NEW SWITCH OR JUST USE A SINGLE KEY INSTEAD OF A FULL SET OF KEYS HANGING FROM THE KEY SLOT.. THE FULL REPLACEMENT OF THE SWITCH RUNS 350$, PRTS AND LABOR.”
“WHILE DRIVING DOWN I-75 IN MICHIGAN DOING ~75MPH, I FEEL A SHARP TUG THEN A SWAY. WE TOOK THE VEHICLE HOME AND INSPECTED IT. THE WELDS ON THE BODY TO THE ATTACHING POINT OF THE REAR AXLE HAD BROKEN AND THE REAR END OF THE VEHICLE WAS TRACKING SIDEWAYS. THANK GOD NOTHING BAD HAPPENED, WE HAD ALL SIX OF OUR KIDS WITH US WHEN IT WENT OUT AT 75MPH.”
“TL* THE CONTACT OWNS A 2006 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE SIDE DOOR HAD OPENED INDEPENDENTLY ON TWO OCCASIONS WHILE THE VEHICLE WAS IN MOTION. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THAT THERE WAS A RELAY PROBLEM THAT CAUSED THE DOOR TO OPEN. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 155,000. RETURNED BY USPS. 2ND ATTEMPT ON 3/15/2013 AND 4/9/2013 FAILED. *KB”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Uplander FWD Auto 4-spd, 6 cyl, 3.5 L · Front-Wheel Drive | 16 | 23 | 18 | $3,450 | 494 |
| Uplander AWD Auto 4-spd, 6 cyl, 3.5 L · 4-Wheel or All-Wheel Drive | 15 | 21 | 17 | $3,650 | 523 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Nov 10, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 196 complaints with NHTSA. The most-cited components are electrical system (57), structure (45), latches/locks/linkages (45). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2005 Chevrolet Uplander at 17–18 mpg combined, depending on engine and drivetrain (2 versions rated).