NHTSA lists 1 safety recall and 12 owner complaints for the 2025 Chevrolet Silverado 3500. Most complaints involve electrical system (4) and power train (3).
General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“The infotainment system regularly stops producing audio. This applies to all audio, including turn signal, navigation, radio and Apple Carplay. Yes, it's available to inspection. While it's not a huge safety concern, there have been a couple times it's quite working, and I was very distracted by the audio cutting in and out. A few times I've driven down the road with my blinker on because I couldn't hear it blinking as it comes through the speakers. Yes, I've taken it to the dealer, they apply software fixes that they know won't correct the issue. It starts right back up a few days later. No, it has not been inspected by the manufacturer, other than their authorized service center. No warning prior to it appearing.”
“We were pulling a 5th wheel camper on the highway at 62 mph. We experienced a series of sudden breaking sensations. Engine RPMs did not change during these events. We had been traveling for 45 minutes and decided to cancel our camping trip and return home because we were afraid of getting stranded away from home. The sensation felt like a sudden strong application of the rear brakes. It was very momentary. We turn around and shifted the transmission to "L" which limits the highest gear to 7. We did not have any more incidents. When we were close to home we shifted back to drive and the problem returned. We were concerned with a complete loss of control or motion if the problem got worse. We have an appointment to have the truck looked at next week. There were/are no diagnostics codes visible on the dash.”
“This truck was parked on a job site, on a flat parking lot over blacktop, doing a regen for the 5th time in just a few days. The truck had 4,000 miles on it. When it completed the regen, we shut the truck off. Within 15 minutes the truck was fully engulfed in flames. A fire investigator looked at it and determined the fire started in the engine bay, below the master cylinder. He said this was a GM problem. As this truck was a replacement truck, for another broken down truck, we were outside the auto coverage on our insurance. The business property is covering the tool loss, and said it isnt worth going after GM as they make it impossible. I know this isnt the only vehicle this has happened to, and they simply refuse to even answer. I want to file a formal complaint against GM, and want them to cover the loss, the loss of use. This is a safety matter as this could have happened driving down the road and caused loss of life.”
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
1 safety recall as of Nov 9, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 12 complaints with NHTSA. The most-cited components are electrical system (4), power train (3), service brakes (3). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.