2025 Chevrolet Silverado 3500 problems

“The infotainment system regularly stops producing audio. This applies to all audio, including turn signal, navigation, radio and Apple Carplay. Yes, it's available to inspection. While it's not a huge safety concern, there have been a couple times it's quite working, and I was very distracted by the audio cutting in and out. A few times I've driven down the road with my blinker on because I couldn't hear it blinking as it comes through the speakers. Yes, I've taken it to the dealer, they apply software fixes that they know won't correct the issue. It starts right back up a few days later. No, it has not been inspected by the manufacturer, other than their authorized service center. No warning prior to it appearing.”

“We were pulling a 5th wheel camper on the highway at 62 mph. We experienced a series of sudden breaking sensations. Engine RPMs did not change during these events. We had been traveling for 45 minutes and decided to cancel our camping trip and return home because we were afraid of getting stranded away from home. The sensation felt like a sudden strong application of the rear brakes. It was very momentary. We turn around and shifted the transmission to "L" which limits the highest gear to 7. We did not have any more incidents. When we were close to home we shifted back to drive and the problem returned. We were concerned with a complete loss of control or motion if the problem got worse. We have an appointment to have the truck looked at next week. There were/are no diagnostics codes visible on the dash.”

“This truck was parked on a job site, on a flat parking lot over blacktop, doing a regen for the 5th time in just a few days. The truck had 4,000 miles on it. When it completed the regen, we shut the truck off. Within 15 minutes the truck was fully engulfed in flames. A fire investigator looked at it and determined the fire started in the engine bay, below the master cylinder. He said this was a GM problem. As this truck was a replacement truck, for another broken down truck, we were outside the auto coverage on our insurance. The business property is covering the tool loss, and said it isnt worth going after GM as they make it impossible. I know this isnt the only vehicle this has happened to, and they simply refuse to even answer. I want to file a formal complaint against GM, and want them to cover the loss, the loss of use. This is a safety matter as this could have happened driving down the road and caused loss of life.”

“The vehicle was driven to a job site in Gowanda NY. The computer indicated it neede to clean the exhaust filter. The truck was parked in an open area on a blacktop parking area. The truck finished a Regen approximately 30 minutes later. The vehicle was shut down and left unattended. Approx 30 minutes later, the driver, heard noises, came around a structure and saw the vehicle was on fire. The driver did attempt to use a fire extinguisher to no avail. They then called 911 and the fire department was dispatched. The department put out the fire but the vehicle is a total loss. As this was a work site, the vehicle was towed to our shop and stored inside. The inland marine insurance company hired a fire investigator, and they looked at the vehicle. They determined the fire originated on the lower firewall in the engine compartment. He paused his investigation, to await a representative of GM to be present for destructive analysis to determine exact cause. The GM case number is XXX. This vehicle had errored multiple times and did Regen every 2-300 miles.”

“On April 13, 2026, I experienced two safety-related malfunctions while driving my 2025 Chevrolet Silverado 3500 LTZ on a two-lane highway in light rain. At approximately 6:24:05 PM, the windshield wipers stopped in the upright position for about 2–3 seconds while the vehicle was in motion, causing a temporary loss of forward visibility. At approximately 6:26:56 PM, while traveling around 65 MPH, the forward collision/adaptive cruise system falsely detected a vehicle in my lane when none was present and applied sudden, hard braking without driver input. This caused a noticeable forward pitch of the vehicle. At approximately 6:27:13 PM, the system again indicated a vehicle ahead when there was none. Road conditions were wet, and this unexpected braking created a risk of loss of control or a rear-end collision. The systems involved include the windshield wipers and forward collision/adaptive cruise control. The vehicle is available for inspection upon request. There were no warning lamps prior to these incidents. The only indication was a false vehicle detection displayed on the instrument cluster and heads-up display. These issues have not yet been reproduced by…”