NHTSA lists 4 safety recalls and 258 owner complaints for the 2003 Chrysler PT Cruiser. Most complaints involve electrical system (45) and power train (35). The EPA rates it 19–22 mpg combined.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTENTLY TO AS HIGH AS 17.1VOLTS, BUT HAS BEEN FREQUENTLY BOUNCING BETWEEN 14.1V -16.7VOLTS. THIS INCREASE OF VOLTAGE TO A UNSAFE LEVEL CAUSES ALL ELECTRICAL ACCESSORIES THAT ARE IN CONNECTED TO THE CHARGING SYSTEM AND ARE OPERATIONAL TO FLASH/ FLICKER. EXTREMELY DISTRACTING AT NIGHT WITH HEADLIGHTS AND DASHBOARD FLASHING/ FLICKERING. AFTER A LOT OF RESEARCH I FOUND OUT THE PCM NEEDS TO BE REPROGRAMMED WITH THE PROPER UPDATED FIRMWARE IN ORDER TO FIX THE FACTORY WEAK PARAMETERS. I SPOKE WITH A SERVICE MANAGER TODAY(NOV 14,2019) AT MY LOCAL CHRYSLER DEALERSHIP (CENTRAL JEEP CHRYSLER DODGE RAM FIAT @ 56 BOSTON PROVIDENCE TPKE, NORWOOD, MA 02062) ABOUT THE PROBLEM AND ASKED TO HAVE MY PCM REPROGRAMMED SINCE ONLY THAT SPECIFIC MODEL CAR MANUFACTURES SERVICE SHOP WILL HAVE THE CAPABILITY AND PCM FIRMWARE TO REPAIR IT. THE MANAGER REFUSED TO DO ANY WORK ON MY CAR SINCE HE SAID, "I WONT TOUCH CARS…”
“The clutch will not disengage every time and never fully disengages. I noticed my car had a recall for this problem in the past, so before doing the work, I called a dealer for Chrysler and was informed that the recall had already been performed. So I took it upon myself at my own expense to have the clutch replaced. It worked fine for a few months, but it started doing the same thing again.”
“I HAD PURCHESED A USED 2003 PT CRUISER AND ON THE HWY HOME SHORT TIME LATER I HEARD CLUNKING SOUND THREE TIMES FIRST WHEN MERGING ONTO HWY FROM CAR DEALERSHIP. FUTHERMORE, ABOUT 10 MIN INTO MY HWY DRIVE HOME I BECAME FRIGHTEND WHEN MY CAR ENDED UP HAVING A MIND IF ITS OWN AND STARED GOING TO THE LEFT SO I TRIED TO TURN STEARING WHEEL TOWARDS RIGHT AND I WAS UNABLE TO CORRECT IT FOR FEW SECONDS AND ENDED ON THE OTHERIDE OF WHITE LINE JUST ABOUT OFF HWY AND INTO GRAVEL BUT AT THAT POINT I SEENED TO REGAIN CONTROL OF MY CAR STEARING AND PROCEEDING BACK BETEEEN YELLOW AND WHITE LINE ON THE HWY, FOLLOWING WAS ANOTHER INCIDENT WAS WHEN I CAME TO COMPLETE STOP FOLLOWING WITH LEFT TURN (STARTED TO MAKE A CLUNKING SOUND EVEN LOUDER).DURNING MY ROUTE I MADE A RIGHT TURN THE SOUND AGAIN. I ENDED UP TAKING IT TO A DEALERSHIP TO TAKE A LOOK AT . THE MECHANIC SAID HE KNEW AT ONE POINT THEY HAD A SAFTY RECALL ON THE SUSPENSION FOR PT CRUSIERS BECAUSE THEY COULD CAUSE INJURY WITH MOTOR VEHICLE ACCIDENTS DUE TO LOSS OF CONTROL AS A RESULT OF LOWER CONTOL ARM /SWAY BAR / AND BAD BALL JOINTS WHICH I PERSONALLY PROB EXPERICEND ON MY WAY HOME FOLLOWING MY PURCHESE OF THE CAR. THE…”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| PT Cruiser Man 5-spd, 4 cyl, 2.4 L · Front-Wheel Drive | 19 | 26 | 22 | $2,900 | 404 |
| PT Cruiser Man 5-spd, 4 cyl, 2.4 L, Turbo · Front-Wheel Drive | 18 | 25 | 21 | $3,800 | 423 |
| PT Cruiser Auto 4-spd, 4 cyl, 2.4 L · Front-Wheel Drive | 17 | 23 | 20 | $3,200 | 444 |
| PT Cruiser Auto 4-spd, 4 cyl, 2.4 L, Turbo · Front-Wheel Drive | 17 | 23 | 19 | $4,200 | 468 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
4 safety recalls as of Oct 30, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 258 complaints with NHTSA. The most-cited components are electrical system (45), power train (35), suspension (35). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 2003 Chrysler PT Cruiser at 19–22 mpg combined, depending on engine and drivetrain (4 versions rated).