NHTSA lists 7 safety recalls and 70 owner complaints for the 2007 Volvo S-Class. Most complaints involve electrical system (16) and structure (8).
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN INCREASED PRESSURE IN THE POWER STEERING SYSTEM. THE POWER STEERING RETURN HOSE MAY BURST AT THE STEERING GEAR DUE TO THE INCREASED PRESSURE, RESULTING IN A LOSS OF POWER STEERING FLUID.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Complaints for each S-Class model year we’ve synced.
| Model year | NHTSA complaints |
|---|---|
| 1998 | 251 |
| 1999 | 415 |
| 2000 | 628 |
| 2001 | 322 |
| 2002 | 216 |
| 2003 | 141 |
| 2004 | 298 |
| 2005 | 140 |
| 2006 | 102 |
| 2007 | 70 |
| 2008 | 52 |
| 2009 | 33 |
| 2010 | 36 |
| 2011 | 15 |
| 2012 | 129 |
| 2013 | 94 |
| 2014 | 26 |
| 2015 | 67 |
| 2016 | 35 |
| 2017 | 26 |
| 2018 | 16 |
| 2019 | 23 |
| 2020 | 9 |
| 2021 | 8 |
“Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety concern for their product.”
“The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.”
“SAFETY CONCERN: 2007 VOLVO S40 ELECTRONIC THROTTLE MODULE FAILURE - CAUSING "REDUCED ENGINE PERFORMANCE" MESSAGE AND VEHICLE (2007 VOLVO S40) SUDDENLY SLOWS DOWN WHILE IN MOTION, LIMPS AND CANNOT GO HIGHER SPEED. HAD BARELY EXITED THE FREEWAY ON 1/24/2017 AND THIS HAPPENED AS I WAS ON RAMP. COULD BE EXTREMELY DANGEROUS IF IT HAPPENED 1 MINUTE BEFORE WHEN ON FREEWAY. TURNED VEHICLE IN RIGHT AWAY TO LOCAL VOLVO DEALERSHIP (WHICH WAS LUCKILY WITHIN 15 MINUTES) AND THEY DIAGNOSED IT TO BE FAULTY ELECTRONIC THROTTLE MODULE NEEDING REPLACEMENT. MILEAGE ON CAR 129,000 MILES. WANTED TO REPORT SO THIS ISSUE CAN BE LOOKED INTO FOR SAFETY CONCERN AND IF THE HUGE COST OF REPLACEMENT CAN BE OFFSET SO OWNERS CAN HAVE PEACE OF MIND REPLACING IT TIMELY IF THERE IS A RECOMMENDATION OR BULLETIN (SIMILAR TO TIMING BELTS ETC. - WHICH I DON'T BELIEVE THERE IS CURRENTLY FOR ELECTRONIC THROTTLE MODULE).”
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
7 safety recalls as of Oct 31, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 70 complaints with NHTSA. The most-cited components are electrical system (16), structure (8), engine (8). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.