2015 Volvo XC60 problems

“On the night of XXX, my 2015 Volvo XC60 exhibited a cluster of electrical failures with a passenger aboard: the panoramic roof switch was unresponsive, the headlights cut out completely, the fuel gauge was inoperative, and the key fob was dead (no unlock, no hatch release; the vehicle sometimes would not start). The next morning, XXX, on [XXX] westbound at approximately 80 mph in heavy traffic, in darkness and a torrential downpour, I switched on the rear fog lights for visibility and the headlights went completely out; the vehicle's electronic systems failed at highway speed. My passenger ([XXX]) and I were not injured. I recorded 28 seconds of video of the instrument panel during the event: the display cycles (warnings present, then gone, then back), the gear indicator changes on its own, and the fuel gauge sits on empty throughout. The vehicle limped to a friend's house and is now parked and cannot be driven. A post-incident diagnostic scan (codes read, not cleared) shows 20 fault codes across 8 modules, centered on the Central Electronic Module — including DIM U042268 (invalid data received from the CEM), ECM codes for a shutdown-timer failure, lost…”

“Vehicle failed to start after short trip (<5 miles) with no electrical power present. Jump started from another car after approximately 1/2 hour. Drove car to home, car stalled in driveway again with no electrical power. Replaced 5 year old battery car started fine then stalled on road during test drive while approaching an intersection and suffered loss of all electrical power including inoperative hazard flashers. Transmission went into park and car could not be moved out of active traffic lane. Car towed to repair shop where cracked fuse at positive battery terminal found (see photos attached). Repair shop contacted a Volvo dealer and was informed they typically see a couple vehicles a week for same issue.”

“02/15/2025 I received a letter for oil consumption recall that was dated on 02/03/2023. Appointment was made same day I received the letter on 02/15/2023 and appointment couldnt be set sooner then 02/23/2023 which is the date the Oil consumption was done at Volvo of Bellevue. They changed the oil and sealed it and had me drive it 1000 miles, they said I didn't have an oil consumption problem and I disagreed because I told them I have to put in oil all the time. They said it has exceeded the 8yr or 100K miles of the extended warranty of the vehicle which ever comes first. I argued it had less then 100K miles when I got the letter on 02/15/2023 and the appointment couldnt be set til 02/23/2025 and Volvo of Bellevue said not to worry about it and they would take care of the recall. But after they had me pay for the oil change they said it exceeded the 100K miles and 8 yrs age of the vehicle. I argued the letter was sent to me after the vehicle was 8 years old and the avg miles of 12K was over 100K miles and I argued this was a known problem with Volvo but they kept on selling these vehicles knowing these vehicles have oil consumption problems. They refused to fix…”

“The vehicle's Supplemental Restraint System (SRS) safety network experienced a total electrical blackout, resulting in complete airbag non-deployment during a severe unibody-deforming hit-and-run collision. The vehicle was stationary when a high-speed car rammed the passenger side and front profile. Kinetic forces split the cast aluminum steering rack housing completely in half, fractured front CV axle joint cages, and shifted the engine subframe mounts (creating physical gaps and shiny mechanical abrasions beneath the rust layer). Despite catastrophic structural distortion—which twisted the greenhouse safety cage and cracked the windshield directly beneath the laser cluster—zero front, side, or curtain airbags deployed. No dashboard SRS warning lights illuminated prior to or after the crash.A post-crash scan by a Master Mechanic confirms high-speed CAN-bus fragmentation, storing module timeouts U016700, U042268, and steering column resistance deployment inhibitors B1C0224, B1CO424, B1C0524. Additional codes include P134600, P134613, P261086, P0A0F68, C006468, B109B15, B116415, and B108467.Teardown reveals extensive, pre-existing saltwater intrusion residue…”

“WE HAVE IN AT LEAST 2 OCCASIONS EXPERIENCE THE FEATURE "CITY SAFETY" ON OUR VOLVO XC60 2015 , BRAKING TO A STOP WHILE WE ARE IN TRAFFIC FOR NO APPARENT REASON. THE COMPANY AS WELL AS THE DEALERSHIP CLAIM THIS IS HOW THE FEATURE IS SUPPOSE TO WORK . ACCORDING TO THEM THE SOFTWARE HAS ITS LIMITATIONS AND THESE LIMITATIONS INCLUDE THE CAR STOPING ABRUPTLY AND DANGEROUSLY. THE FEATURE CAN BE TURNED OFF BUT IT WILL RESET ITSELF TO ON EVERY TIME THE CAR IS RESTARTED. THE ADVICE WAS FOR US TO TURN THE FEATURE OFF EVERY TIME WE DRIVE IN THE CITY AND OR THROUGH FOG WITH DEFEATS THE PURPOSE OF A FEATURE CALLED "CITY SAFE" . WE BELIEVE THAT THE COMPANY DOES NOT WANT TO ADMIT THAT THE FIRST GENERATION OF THIS FEATURE IS NOT STREET SAFE . THANK YOU”

“TL* THE CONTACT OWNS A 2015 VOLVO XC60. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE WHEEL HUBS FAILED. THE CONTACT HEARD A GRINDING, THUMPING, AND CLUCKING NOISE WHILE TURNING LEFT OR RIGHT WHEN DRIVING IN LOCAL TRAFFIC. THE VEHICLE AND THE FRONT DRIVERS SIDE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO FOUND THAT THE FRONT WHEEL HUBS WERE SEPARATED. THE VEHICLE WAS TAKEN TO PARKWAY VOLVO (5920 MARKET STREET, WILMINGTON, NC 29405, (910)-392-4888) AND THE FRONT PASSENGER SIDE WHEEL HUB WAS REPAIRED WITH HUB SERVICE KIT PART NUMBER: 31360096. THE CONTACT STATED THAT THE SERVICE KIT CONTAINED A HUB PLATE AND SCREWS. THE MANUFACTURER PROVIDED A TECHNICAL SERVICE BULLETIN FOR THE WHEEL HUB FAILURE (TSB NUMBER: TJ25329). THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 52,000. *DT”