2015 Volvo XC60Recalls, problems, MPG & safety

“On the night of XXX, my 2015 Volvo XC60 exhibited a cluster of electrical failures with a passenger aboard: the panoramic roof switch was unresponsive, the headlights cut out completely, the fuel gauge was inoperative, and the key fob was dead (no unlock, no hatch release; the vehicle sometimes would not start). The next morning, XXX, on [XXX] westbound at approximately 80 mph in heavy traffic, in darkness and a torrential downpour, I switched on the rear fog lights for visibility and the headlights went completely out; the vehicle's electronic systems failed at highway speed. My passenger ([XXX]) and I were not injured. I recorded 28 seconds of video of the instrument panel during the event: the display cycles (warnings present, then gone, then back), the gear indicator changes on its own, and the fuel gauge sits on empty throughout. The vehicle limped to a friend's house and is now parked and cannot be driven. A post-incident diagnostic scan (codes read, not cleared) shows 20 fault codes across 8 modules, centered on the Central Electronic Module — including DIM U042268 (invalid data received from the CEM), ECM codes for a shutdown-timer failure, lost…”

“Vehicle failed to start after short trip (<5 miles) with no electrical power present. Jump started from another car after approximately 1/2 hour. Drove car to home, car stalled in driveway again with no electrical power. Replaced 5 year old battery car started fine then stalled on road during test drive while approaching an intersection and suffered loss of all electrical power including inoperative hazard flashers. Transmission went into park and car could not be moved out of active traffic lane. Car towed to repair shop where cracked fuse at positive battery terminal found (see photos attached). Repair shop contacted a Volvo dealer and was informed they typically see a couple vehicles a week for same issue.”

“02/15/2025 I received a letter for oil consumption recall that was dated on 02/03/2023. Appointment was made same day I received the letter on 02/15/2023 and appointment couldnt be set sooner then 02/23/2023 which is the date the Oil consumption was done at Volvo of Bellevue. They changed the oil and sealed it and had me drive it 1000 miles, they said I didn't have an oil consumption problem and I disagreed because I told them I have to put in oil all the time. They said it has exceeded the 8yr or 100K miles of the extended warranty of the vehicle which ever comes first. I argued it had less then 100K miles when I got the letter on 02/15/2023 and the appointment couldnt be set til 02/23/2025 and Volvo of Bellevue said not to worry about it and they would take care of the recall. But after they had me pay for the oil change they said it exceeded the 100K miles and 8 yrs age of the vehicle. I argued the letter was sent to me after the vehicle was 8 years old and the avg miles of 12K was over 100K miles and I argued this was a known problem with Volvo but they kept on selling these vehicles knowing these vehicles have oil consumption problems. They refused to fix…”