2003 Toyota Tacoma problems

“While driving at both high speeds (highway) and local road speed limits, Toyota Tacoma's rear passenger side frame split completely in half. While performing maneuvers such as right turns, vehicle wobbled and I, driver, lost temporary control of vehicle. Upon further inspection, rear driver side frame also contains stress fractures which are symmetric to the rear passenger side of truck. Potential for accident has increased exponentially. Pictures provided. Brought evidence of clear safety hazard to local Metro Detroit dealership at 773 S Rochester Rd Unit B, Rochester Hills, MI 48307 on 04NOV25, and called Toyota Corporate on 05NOV25. Toyota Corporate neglected my concerns about safety hazard and potential harm to myself and family. Safety recall needs to be issued immediately. This issue stems from a well known recall from Toyota of Toyota Tacoma's, 1996-2004, which contained an OEM defect of excessive corrasion to the frames, causing premature failure of the frames due to excessive rust build up which impacts frame integrity and increases probability of failures such as observed in my case.”

“I took my 2003 Toyota Tacoma and for a tire alignment and was told by an employee of the tire shop that my rack and pinion needed to be replaced and lower ball joints. I checked the VIN number and it said I have zero recalls, but there is a general recall on this make a model that I have what do I do? I also have the steering has a lot of play whenever I go for a bump in the road like the tires catch the road so I kind of swerve a little bit and I feel that it’s very unsafe to me and other drivers.”

“The contact owned a 2003 Toyota Tacoma. The contact stated that while driving up the driveway at 5 MPH and turning into the garage, the accelerator pedal was depressed but went down to the floorboard and became stuck. The contact lost control of the vehicle, and the vehicle crashed into the fence gate and the corner of the neighbor's residence. The air bags did not deploy. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to NHTSA Campaign Number: 09V388000 (Vehicle Speed Control). The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 230,000.”

“I was traveling on highway 12 at 60 mph when the seat belts exploded and cinched up tight to child safety lock mode. There was an odor of burning wires/electrical.”

“TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 40 MPH OVER A BUMP AND DEPRESSING THE BRAKE PEDAL, THE TRANSMISSION JERKED SUDDENLY. THE FAILURE OCCURRED EVERY DAY FOR THE PAST MONTH. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 212,000.”

“The contact owns a 2003 Toyota Tacoma. The contact received notification of the NHTSA Campaign Number: 12V542000 (Tires) and the vehicle was taken to the dealer for the recall repair; however, the dealer declined to perform the recall repair due to rust on the subframe, and the spare tire carrier needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the issue and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 236,000.”