NHTSA lists 2 safety recalls and 100 owner complaints for the 1996 Ford Bronco. Most complaints involve vehicle speed control (23) and service brakes, hydraulic (18). The EPA rates it 12–14 mpg combined.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“TL* THE CONTACT OWNS A 1996 FORD BRONCO. WHILE PARKED, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT ATTEMPTED TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER BUT WAS UNABLE TO CONTROL THE FIRE. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE WAS 180,000.”
“WHILE APPROACHING AN INTERSECTION, THE CONSUMER APPLIED THE BRAKE PEDAL, AND IT HAD GONE TO THE FLOOR. THE CONSUMER PUMPED THE BRAKES, AND VEHICLE HAD COME TO AN ABRUPT STOP. PH THE CONSUMER FOUND THAT THE BRAKE LINE HAD RUSTED AND BURST WHICH CAUSED THE BRAKING FLUID TO LEAK. SCC”
“WHILE DRIVING VEHICLE WOULD NOT GO FORWARD. CONSUMER STATED TRANSMISSION WENT OUT. DEALER CONTACTED. *AK CRUISE CONTROL AND DOOR LOCKS ARE INOPERATIVE. EMERGENCY BRAKE LIGHT STAYS ILLUMINATED. FRONT END IS OUT OF ALIGNMENT AND PULLS TO THE LEFT. HEAD LIGHTS WILL NOT SHUT OFF. THERMOSTAT, RADIATOR, RADIATOR CAP, AND WATER PUMP WERE REPLACED. THE STRUTS THAT HOLD THE BACK WINDOW AND DOOR DID NOT HOLD, SPRINGS FOR THE BACK DOOR ARE INOPERATIVE. TRANSMISSION NEEDED ADJUSTMENT, BALL IN TRANSMISSION FAILED, VEHICLE WILL NOT SHIFT INTO 4-WHEEL DRIVE, AND UNIVERSAL JOINT WAS REPLACED. DRIVER SIDE SEAT BELT INOPERATIVE. ELECTRICAL SWITCH THAT ADJUSTS THE DRIVER SEAT SHORTED OUT AND CAUGHT FIRE IN THE ENGINE COMPARTMENT, GROUND CABLE ON THE BATTERY BROKE CAUSING COMPUTER TO BE INOPERATIVE, STARTER SWITCH, SOLENOID, LOCK CYLINDER, CIRCUIT BREAKER, AND TEM SENSOR WERE REPLACED. AIR CONDITIONER FAILED AND VENTS DO NOT WORK. *SLC”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Bronco 4WD Man 5-spd, 8 cyl, 5.0 L · 4-Wheel or All-Wheel Drive | 13 | 16 | 14 | $4,600 | 635 |
| Bronco 4WD Auto 4-spd, 8 cyl, 5.0 L · 4-Wheel or All-Wheel Drive | 11 | 16 | 13 | $4,950 | 684 |
| Bronco 4WD Auto 4-spd, 8 cyl, 5.8 L · 4-Wheel or All-Wheel Drive | 11 | 15 | 12 | $5,350 | 741 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
2 safety recalls as of Oct 28, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 100 complaints with NHTSA. The most-cited components are vehicle speed control (23), service brakes, hydraulic (18), visibility (13). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1996 Ford Bronco at 12–14 mpg combined, depending on engine and drivetrain (3 versions rated).