1999 Toyota RAV4 problems

“I lost control of the vehicle and I overcorrected causing the car to go airborne. I hit head on into an embankment then continued to roll 3or 4 times before stopping. There were no indications or warnings to make me think these parts were going to malfunction. My airbags never deployed and the seatbelt did not lockup.”

“TODAY I WAS BACKING OUT OF A PARKING SPACE AND MY ENGINE SURGED. I WAS ABLE TO STOP THE CAR BY BRAKING AS HARD AS POSSIBLE, AND EVEN THEN IT WAS DIFFICULT TO STOP. THIS IS THE FIRST TIME IT HAS SURGED WHILE BACKING UP. ON NUMEROUS OCCASIONS OVER THE YEARS THE ENGINE HAS SURGED WHEN THE CAR IS SLOWING DOWN AT A STOPLIGHT OR STOP SIGN, AND USUALLY WHEN I'M GOING UNDER 10 MILES AN HOUR. VERY SCARY! THERE IS NO PROBLEM WITH MY FLOOR MAT, WHICH IS FASTENED SECURELY WELL BELOW THE BRAKE AND GAS PEDALS.ALSO, I'VE NEVER BEEN DISORIENTED AND UNABLE TO TELL WHERE MY FOOT IS. I DON'T DRINK OR SMOKE, AND HAVE A GOOD SAFETY RECORD WITH STATE FARM FOR OVER 40 YEARS. I'VE REPORTED THIS SURGING PROBLEM NUMEROUS TIMES TO TOYOTA AND THEY CAN'T SEE ANYTHING WRONG WHEN THEY TEST DRIVE. THAT'S BECAUSE THE SURGING PROBLEM OCCURS IRREGULARLY, ABOUT ONCE IN EVERY 50 TIMES I BRAKE. AT VARIOUS TIMES I'VE ASKED OTHER DRIVERS OF RAV 4 CARS IF THEY'VE HAD THIS PROBLEM, AND SEVERAL HAVE SAID YES. TOO BAD I NEVER TOOK DOWN THEIR NAMES. I'VE ALSO REPORTED THIS BEFORE TO THE NHTSA, AND NOTHING CAME OF IT. I HAVE FAITH THAT ONE DAY THE PROBLEM WILL BE ACKNOWLEDGED. I'M A RETIRED FEDERAL…”

“TL* THE CONTACT OWNS A 1999 TOYOTA RAV. WHEN THE IGNITION WAS TURNED TO THE OFF POSITION IN THE EVENING, THE RADIO WAS ACTIVATED THE NEXT MORNING. ALSO, THE FAN IN THE ENGINE WAS RUNNING AND CAUSED THE BATTERY TO DRAIN. THE IGNITION WAS TURNED TO THE ON POSITION, BUT THE VEHICLE FAILED TO START. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE STALLED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED ON SOME OCCASIONS, BUT THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THEFT DETERRENT SYSTEM FAILED AND NEEDED TO BE REMOVED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES RECURRED AND RENDERED THE VEHICLE INOPERABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 98V278000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.”

“WE TOOK THE RAV4 INTO THE MECHANIC FOR A BRAKE JOB & HE CALLED US TO SAY IT WASN'T ROAD WORTHY BECAUSE THE K-FRAME WAS ALMOST ENTIRELY RUSTED THROUGH AND WE SHOULDN'T PUT OUR CHILDREN IN IT. HE SAID WE SHOULDN'T EVEN DRIVE IT OFF HIS LOT THAT IT COULD HIT A POTHOLE AND BREAK IN TWO. WE CAME & TOOK PICTURES OF ALL THE RUST. HE SAID THE K-FRAME WOULD NEED TO BE REPLACED ALONG WITH THE ROCKER ARMS. WE CAME HOME & RESEARCHED TO FIND THIS IS A COMMON PROBLEM WITH THESE VEHICLES. I DON'T UNDERSTAND WHY A COMPANY LIKE TOYOTA WOULDN'T TAKE RESPONSIBILITY FOR A DEFECT LIKE THIS. IT'S CLEARLY A DESIGN FLAW. IMAGINE THE CATASTROPHIC DAMAGE AND INJURY THAT WOULD OCCUR IF I HAD MY CHILDREN IN THIS VEHICLE DRIVING 65MPH DOWN THE HIGHWAY (THAT I HAVE TO TAKE EVERYDAY TO GET ANYWHERE) AND THE FRAME ON THIS VEHICLE BREAKING! I HATE TO THINK WHAT WOULD HAPPEN TO ME OR MY CHILDREN. ALL BECAUSE TOYOTA DIDN'T MAKE SURE TO MAKE A FUNCTIONAL PART OF THE SUPPORT STRUCTURE OF THEIR VEHICLES.”

“BOTH OF THE FRONT SEAT BELT CONNECTIONS HAVE STOPPED LATCHING INTO AND LOCKING THE SEAT BELT. I HAD THE DRIVERS SIDE REPLACED ABOUT A YEAR AGO, IT WAS STILL UNDER WARRENTY. NOW THE PASSENGER SIDE IS NOT WORKING. IS THERE A PROBLEM WITH THE CONNECTIONS IF SO WHY AND WHAT IS NEEDED TO BE DONE. *AK”

“WHILE DRIVING ON 2 LANE ROAD APPROACHING A STOP LIGHT, THE LIGHT TURNED RED AND CAR BRAKES FOR STOP, AT WHICH TIME THE THE LOWER A FRAME COLLAPSED, FORCING CAR TO THE LEFT AND INTO THE CURB, DRIVER SIDE TIRE WAS FORCED UP INTO THE WHEEL WELL. NO INJURIES OCCURED DUE TO LOW SPEED!! HOWEVER WHAT IF IT HAPPENED AT HIGHWAY SPEED??? CHECKED THE OTHER SIDE AND THE "STEEL" A FRAME "CRUMBLED IN MY HAND!!! CAR IS NOT DRIVABLE. HARD TO BELIEVE YOU HAVE FAITH THAT THIS CRITICAL MEMBER COULD FAIL SO VIOLENTLY?? HOPE THIS HELPS OTHERS, CHECK NOW!!!!! *TR”