2023 Toyota Tundra problems

“Recall was issued a year ago on my engine and toyota has yet to do anything about the recall. There is also a second recall for ym tailights , this has been over a year since the recall was issued. First they told me i was to get a new engine in june of 2026. Then in may of 2026 they told me a software test will be completed first to determine if my truck needs a engine. The dealer did state at that time , they are not equipped or trained to perform the service so they dont know when this will happen if ever.”

“2023 Toyota Tundra. On July 20, 2026 and again on September 18, 2026, while driving, the truck suddenly lost power and went into limp mode. The dash showed 'Check Engine / Reduced Engine Power / Visit Your Dealer' at about 43,440 miles. The truck had to be towed to the dealer on a flatbed. Losing power without warning in traffic is a serious safety risk. Other ongoing problems: the brakes squeaked for over a year before they were fixed, the driver seat bolster plastic is broken (this would be the third repair), the radio volume knob has failed, and there is excessive wind noise. This VIN still shows open recall 25V767 (engine machining debris causing loss of motive power), which has not been performed despite two dealer visits for this exact failure.”

“Vehicle: 2023 Toyota Tundra TRD Pro Hybrid, VIN [XXX], approximately 40,000 miles. The electronic fuel door release failed due to a corroded fuel door sensor/connector (diagnosed by Premier Toyota, XXX). When the fuel door system does not engage, the tank's refueling valve does not open. As a result, gasoline spits back out of the filler neck during refueling, spilling fuel onto the vehicle and the ground. This creates a fire hazard at fuel stations. Many other owners of 2022-2024 Tundra Hybrid trucks report the identical failure. I believe this is a manufacturing defect in a sealed electrical component that creates a fuel-spill safety risk.”

“The contact owns a 2023 Toyota Tundra. The contact stated that while driving 65 MPH, the vehicle stalled with an audible beeping sound. The engine symbol with an exclamation mark was illuminated for approximately 2 seconds. The message "Engine Stopping - Get to safe side of Road" was immediately displayed on the instrument panel. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling) and associated the failure with the recall; however, the part to do the recall repair was not yet available. The vehicle was towed to the local dealer. The diagnostic result was inconclusive. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 45,000.”

“The contact owns a 2023 Toyota Tundra. The contact stated that while starting the vehicle, the check engine, Auto Start/Stop, and another unknown warning light illuminated. The message "Grill Shutter Malfunction Low Voltage" was displayed. The vehicle was taken to the dealer, who determined that the battery sensor, alternator, and ECU had short-circuited. The dealer replaced the battery sensor, alternator, and ECU; however, the failure persisted with the check engine and another unknown warning light illuminated. The vehicle was taken back to the dealer, who determined that the grill shutter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 57,000.”

“-Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the front right side) and then I suddenly lost complete power. I was traveling in the number one lane (the fast lane). I immediately put my hazards on and had to navigate to the number two lane and then over to the narrow shoulder under no power whatsoever. I had to navigate around multiple semi-trucks. This was a very dangerous situation and I barely got it over to the shoulder. If my teenage daughters were driving this car they likely wouldn't have been able to safely navigate it across two lanes with no power in the setting of multiple semi-trucks on a two-lane divided highway. Again, a very dangerous situation. I shut down the engine and waited five minutes and restarted it. Shifting into gear the warning indicator said 'hybrid system disconnected'. -The total…”