2019 Ford Transit Connect problems

“Since I’ve bought it at 48,000 miles the van has always had hard engagements on 1 gear and 2nd. I knew the transmission was bad a week after I bought it at the ford dealership. All they did under their limited warranty was a transmission flush. Now it has 70,000 and the torque converter is toast now. I was on the interstate going 70mph. Let off the gas and a huge aggressive deceleration happened and I almost lost control. It is constant issue now when going over 70mph. Took it to ford, no transmission codes so they didn’t try fix it or find anything wrong. Noticing high rpms trying to get up to speed. Torque converter is clearly slipping.”

“The vehicle has only been driven for 24K miles and there was an issue with the ABS Hydraulic Control Unit (HCU) and the recommendation is for it to be completely replaced. Seems ridiculous if the ABS Hydralic Control Unit is meant to last 100k-200k miles.”

“The contact owns a 2019 Ford Transit Connect. The contact stated while the vehicle was parked, the electrical system failed to respond, and the vehicle turned off. There were no warning lights illuminated. There was no power to the vehicle. The vehicle was towed to the dealer where unknown repairs were performed along with a taillight repair. On a separate occasion, while driving 30 MPH, the vehicle failed to respond, the transmission was not shifting properly, which caused the vehicle to jerk. The contact stated that while driving after the engine had warmed up, the vehicle would unintendedly stop. The contact returned from a trip and the vehicle was taken to a dealer and was diagnosed with transmission failure. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 84,500.”

“Description of Defect: When the vehicle is shifted into reverse, the rearview camera display freezes for several seconds before going black. This malfunction creates a direct and serious safety hazard — during the period the display is frozen, the image shown does not reflect actual real-time conditions behind the vehicle. Any pedestrian, child, or object that moves into the path of the vehicle after the display freezes will not be visible to the driver. This significantly increases the risk of a backover collision. Dealership Inspection Outcome: I brought the vehicle to an authorized Ford dealership for diagnosis. Upon inspection, the technician was unable to detect the diagnostic trouble code associated with Recall 25S89, and as a result, the vehicle was deemed to have passed inspection. However, the malfunction continues to occur. The failure to trigger the recall code does not resolve the underlying issue — the camera display still freezes and blacks out during reverse operation, leaving the driver without a functioning rearview safety system. Safety Concern: A rearview camera is a federally mandated safety feature. A display that intermittently freezes and…”

“During a rainy day, I had water coming in from around the top driver's side windshield and from the inside light above the dash. According to my VIN there are no recalls, but apparently there have been recalls on the seal around the windshield on some. I have not had the vehicle inspected by the dealer. The problem began last month (January 2025) and each time it rains I have issues with leaking.”

“Jerks when accelerating, loses power, hesitates backing up, brake on left front does not release and overheats, right back brake following suit. Took into repair shop for brake service. Quote the inspection "Front passenger caliper seized no flow from house caused caliper to lock up." Was advised after rear right brake was found to be developing the same symptoms to have it towed to dealership for further inspection--risk of brake failure increasing likelihood of crash was cited as reasoning to default to dealership and no longer drive the vehicle.”