2022 Ford Transit Connect problems

“Ford is using a heavy, wax inside the bottom of the door/side panels. When the weather gets hot, this wax softens, and runs downward, and solidifies directly over the tiny weep holes at the bottom of the doors, trapping rain and wash water inside the door panels. I Always have to clear the weep holes over and over after a carwash or rain storm. The windshield Leakes water and drips on the dashboard. I believe the trapped musty water and leaks cause dampness creating several critical safety, structural, electrical corrosion and health hazards. Ford won't repair the windshield leak because it's not cover under my premium care warranty Ford has failed to respond about my complaint about the wax in my doors. I fined that the moisture creates intermittent electrical issues of all kinds, like vent controls intermittently working various switches not functioning the first time and and have to clean or rock them to work, (intermittent popping of fuses or relay prematurely operating ). These Intermittent options/features don't work right when/as expected and believe causing a safety hazard. This standing water will breaks down the inner metal panels, leading to severe…”

“The radioator failed it started leaking the car is only 60k ish miles”

“The factory windshield is loose/improperly bonded causing MOLD. This problem was found when i first bought the only four year old vehicle because of a musty/moldy smell. On the way home from the dealership it happened to storm and there were a few raindrops coming in at the top center of the windshield. I also had terrible allergy symptoms and headaches after only a few minutes of driving. I peeked under part of the vinyl floor and discovered major water and mold issues. I took it to my local Ford dealership who confirmed the windshield was likely the culprit as it was very loose. I researched this online and found an auto leak specialist demonstrating this same make/year/model van that the windshield could be easily moved simply by pushing lightly on the glass from inside the cabin, showing a bonding issue. This was the case on my van as well. This is the same issue that there WAS a recall for on the previous model (there just isn't one for this model yet) The damage was extensive and very dangerous for people like me who are sensitive to mold and can cause respiratory issues. I removed the seats and floor. There was approximately half gallon of water under…”

“While driving my 2022 Ford Transit Connect (cargo model, 2.0L) in city traffic, I experienced a serious intermittent issue. Twice now, the vehicle suddenly jerked, throttle response was delayed or non-existent, and a “Collision Detection Disabled” warning flashed on the dash. Simultaneously, the “Service Vehicle Soon” light illuminated. Both times, I pulled over and shut off the vehicle. Upon restarting, the warnings cleared and the vehicle drove normally again. There were no prior warning signs or fault messages. I brought the vehicle to Mullinax Ford in Apopka, FL, and explained the issue in detail. However, I was told there were no diagnostic trouble codes (DTCs) stored, and they refused to conduct any further testing. I specifically asked them to perform: A full scan of all vehicle modules (including the IPMA/collision system), Check the forward collision camera and wiring, Confirm all PCM/ADAS software is up to date, Perform a battery and charging system test, Inspect the throttle body or related sensors. They declined, saying “if there are no codes, there’s no issue.” This is concerning because the symptoms are intermittent and potentially safety-related…”