2016 Kia Sorento problems

“Vehicle caught on fire when driving, putting my mother's life and her passenger at risk. My mother is an elderly Deaf woman, but was able to pull over in time for Fire Department to help contain fire. There were no warning lamps or messages of any problems with car, the car started smoking (smoke also entered cabin) and they pulled over where there was a fire under hood and bystander call emergency services. The car is currently at a tow lot and should be available for inspection upon request. We are waiting for car to be inspected by insurance.”

“Upon a catastrophic engine failure Tasca Kia replaced engine under Theta II settlement. I picked up my kia on 9/12. Engine is not running properly. It’s jerking and there is loud mechanical knocking. I don’t feel safe driving. I’ve contacted Kia corporate beginning 9/16 who contacted Tasca to arrange for tow and loaner. They said Tasca service mgr would contact soon to set up. They never did. I called corporate again later that day and after they called Tasca they were told service mgr went home for the day. As of this date Tasca Kia has not contacted me. I again called Kia corporate 9/17 asking to please escalate and allow me to use another service dept. The only other service location with loaner is a half hour away and I cannot afford another tow or another rental. I am stranded with a car that is not safe due to installation failure or another defective engine. No one from Kia will help in a reasonable time frame. I’m now told it can take up to 48 BUSINESS HOURS for any assistance. In the meantime I’m being forced to decide on whether to risk driving an unsafe vehicle to the service dept or to continue waiting for Kia to contact me.”

“I am the original, single owner of a 2016 Kia Sorento in Snow White Pearl. My vehicle currently has approximately 96,000 miles on it. Roughly one year ago, the factory paint began catastrophically peeling, flaking, and deteriorating in large sheets on the roof and near the passenger-side door. This damage is not the result of environmental wear, stone chips, or poor maintenance. It is a documented, widespread manufacturing defect—specifically, a factory primer-adhesion failure (delamination)—that uniquely impacts Kia and Hyundai vehicles painted in this specific Snow White Pearl finish. I contacted Kia Consumer Care to resolve this issue and was assigned Case Number 26409995. Despite my status as a loyal, original owner of a vehicle under 100,000 miles, Kia issued a blanket denial of assistance. Kia is well aware of this systemic manufacturing defect, as their sister company Hyundai has previously extended paint warranties to 10+ years for identical white paint delamination issues. Kia’s refusal to remedy this known defect constitutes unfair and deceptive consumer business practices under California law. My vehicle specifically features Kia’s "Snow White…”

“I am filing a safety complaint regarding a severe, sudden electronic and mechanical failure of the shift interlock system and the Body Control Module (BCM) that compromises vehicle control and leaves the vehicle stranded in active traffic conditions. While attempting to operate the vehicle, the shifter lever suddenly became physically jammed and highly resistant, refusing to shift out of the "Park" position or smoothly engage into "Drive." Simultaneously, the gear selector indicator (P-R-N-D) on the digital dashboard display went completely blank, indicating a total loss of network communication between the transmission range system and the vehicle's central computer network. Because the vehicle's electronic safety "handshake" failed, the vehicle suffered a no-start condition. To operate the vehicle or move it out of harm's way, I am forced to use the mechanical manual shift-lock override tool. Diagnostic scanning at a professional repair facility confirmed a hard Code P0955 (Auto Shift Manual Mode Circuit Malfunction) due to an internal electronic failure inside the Body Control Module (BCM), which handles the safety grounding circuit for the shift interlock…”

“The Steering binds/ sticks at the 12 o’clock position on the highway, requiring sudden extra physical force to break free, which causes the vehicle to oversteer left to right. For record, Auffenberg Kia verified a steering torque measurement of 7.3 Nm (failure limit: 4.5 Nm) per TSB CHA060, but denied warranty repair under WTY023 solely because the instrument cluster lamp was not illuminated. I paid $163.69 and the dealer released an unsafe car back to me.”

“I have now replaced the headlight bulbs in my 2016 KIA Sorento 6 times and it's getting worse as it gets older. I believe it is a safety issue since the last time I was out of town, traveling in the middle of the night when it went out. I had to wait until morning to find an auto parts store to buy and replace the bulb. No inspections have been done by anyone. Yes, the warning lamp comes on and stays until reset.”